CATIA V5
Part & Assembly Design
Sample Exam
2015/06/19
DISCLAIMER:
The purpose of this sample exam is to show you the format and approximate difficulty level of the questions that you will find in the
CATIA V5 Part and Assembly Design real exams. It is not meant to give away the whole exams content
The questions are examples of what to expect in the following three areas:
Part Modeling
Assembly Creation
Drafting (there are Drafting questions in both Part and Assembly Design exams)
Note that some data are provided to perform the Assembly
1.
2.
Auxiliary View
Detail View Profile
Breakout View
Offset Section View
A = 81.00
B = 57.00
C = 43.00
o
o
o
o
1028.33
118.93
577.64
934.72
Use the part created in the previous question and modify it by changing the following parameters:
A = 84.00
B = 59.00
C = 45.00
Note: Assume all other dimensions are the same as in the previous question.
Use the part created in the previous question and modify it by removing material and also by changing the following parameters:
A = 86.00
B = 58.00
C = 44.00
10
11
12
13
14
Using the same assembly created in the previous question modify the following parameters:
A = 30 degrees
B = 115 degrees
C = 135 degrees
What is the Center of Gravity of the assembly (millimeters)?
-----------------------------------------
Answers
15
1.
2.
c) Breakout View
3.
d) 934.72 g
4.
1027.09 g
5.
647.25 g
6.
452.64 g
7.
8.
16