Version 1.0
TABLE OF CONTENTS
TABLE OF CONTENTS
Introduction
Special Features
Lithium Polymer Balance Charge Program Connection Diagram
Warning and Safety Notes
Program Flow Chart
Initial Parameter Setup (Users Set Up)
Lithium (LiPo/Lilon/LiFe) program
Charging Lithium Battery in Charge Mode
Charging Lithium Battery in Balance Mode
Fast Charging of Lithium Battery
Charging Lithium Battery in the Fast Charge Mode
Storage Control of Lithium Battery
Charging Lithium Battery in the Storage Mode
Discharging of Lithium Battery
Voltage Balancing and Monitoring in the Discharge Process
Charging of NiCd/NiMH Battery
Charging NiCd/NiMH Battery in the Charge Mode
Discharge of NiCd/NiMH Battery
02
03
05
06
11
12
15
16
16
17
17
18
18
19
19
20
20
20
Charge/Discharge and Discharge/Charge Cycle of NiCd/NiMH Battery 21
Charging of the Pb Battery
21
Charging Pb (lead-acid) Battery in the Charge Mode
22
Discharging of the Pb Battery
22
Data Storage Program
23
Load Data Program
24
Various Information in the Program
25
Warning and Error Message
26
Specifications
27
Warranty and Service
27
- 01 -
INTRODUCTION
INTRODUCTION
Balance
Socket
Scroll Through
the Main Menu
Stop any Charge
Processes
Output
Alter Values Cells
Charging
in Balance Charge Mode
See the Status of Individual
Resume or Start Charge Processes
Confirm an Action
- 02 -
SPECIAL FEATURES
SPECIAL FEATURES
- 03 -
SPECIAL FEATURES
- 04 -
WARNING:
Failure to connect as shown in this diagram will damage this
charger.
The main battery leads must be connected along with the balance
lead connector as shown before charging your battery .
- 05 -
- 06 -
NiCd/NiMH
- Voltage level: 1.2V/cell
- Allowable fast charge current: 1C-2C (depends on the
performance of cell)
- Discharge voltage cut off level: 0.85V/cell (NiCd),
1.0V/cell(NiMH)
Li-ion
- Voltage level: 3.6V/cell
- Max. charge voltage: 4.1V/cell
- Allowable fast charge current: 1C or less
- Min. discharge voltage cut off level: 2.5V/cell or higher
LiPo
- Voltage level: 3.7V/cell
- Max. charge voltage: 4.2V/cell
- Allowable fast charge current: 1C or less
- Discharge voltage cut off level: 3.0V/cell or higher
LiFe
- Voltage level: 3.3V/cell
- Max. charge voltage: 3.6V/cell
- Allowable fast charge current: 4C or less
- Discharge voltage cut off level: 2.0V/cell or higher
Pb
- Voltage level: 2.0V/cell
- (Lead-acid) Max. charge voltage: 2.46V/cell
- Allowable fast charge current: 0.4C or less
- Discharge voltage cut off level: 1.75V/cell or higher
- 07 -
- 08 -
Have you checked that all connections are firm and secure?
Make sure there are no intermittent contacts at any point in the
circuit.
Charging
During charge process, a specific quantity of electrical energy is
fed into the battery. The charge quantity is calculated by
multiplying charge current by charge time. The maximum
permissible charge current varies depending on the battery type
or its performance, and can be found in the information by the
battery manufacturer. Only batteries that are expressly stated to
be capable of quick-charge are allowed to be charged at rates
higher than the standard charge current.
Connect the battery to the terminal of the charger: red is positive
and black is negative. Due to the difference between resistance
of cable and connector, the charger can not detect resistance of
the battery pack, the essential requirement for the charger to
work properly is that the charge lead should be of adequate
conductor cross-section, and high quality connectors which are
normally gold-plated should be fitted to both ends.
Always refer to the manual by the battery manufacturer pertaining
to charging methods, recommended charging current and
charging time. Especially, the Lithium battery should be charged
according the charging instruction provided by the manufacturer
strictly.
Attention should be paid to the connection of Lithium battery
especially.
Do not attempt to disassemble the battery pack arbitrarily.
- 09 -
- 10 -
- 11 -
LiFe
V.Type
3.3V
- +
DEC INC
DEC INC
- 12 -
DEC
INC
- +
DEC INC
DEC
INC
Temp. Cut-off
ON
80C
- +
DEC INC
DEC
- +
DEC INC
INC
Waste time
CHG/DCHG 5min
- +
DEC INC
DEC
- +
DEC INC
INC
- 13 -
INC
Safety time
ON
120min
- +
- +
DEC INC
DEC INC
INC
DEC
INC
Key Beep
Buzzer
ON
ON
- +
DEC INC
DEC
INC
- 14 -
Start
Enter
Battery
voltage
Charging Charged
capacity
current
- 15 -
Start
Enter
Battery
voltage
Charging Charged
current
capacity
- 16 -
Enter
>3 seconds
R:3SER S:3SER
CONFIRM(ENTER)
Start
Enter
Current
voltage
battery
Charging Supplied
current
capacity
Number Charging
of cells time
- 17 -
- +
DEC INC
- +
DEC INC
Current
voltage
battery
Charge or Supplied
discharge capacity
current
Number Elapsed
of cells time
- 18 -
- +
DEC INC
DISCHARGE
11.1V(3S)
- +
DEC INC
Battery
voltage
Discharge Discharged
current
capacity
INC
- 19 -
Enter
Enter
>3 seconds
Discharged
capacity
- 20 -
- +
- +
DEC INC
DEC INC
Batt type Start
>3 seconds
Stop
Enter
Battery Elapsed
type
time
Discharge Discharged
or charge or charged
current
capacity
DCHG
CHG
1
1
1314mAh
1430mAh
Enter
Battery
voltage
Charged
capacity
- 21 -
Enter
>3 seconds
Battery
voltage
Discharge Discharged
capacity
current
- 22 -
- +
DEC INC
DEC INC
NiMH DISCHARGE*
1.0A
11.0V
- +
- +
DEC INC
DEC INC
DEC INC
NiMH CYCLE
DCHG>CHG
- +
DEC INC
*
3
- +
Save ...
- 23 -
Load ...
- 24 -
DEC
Safety
ON
Timer
200min
DEC
Temp. Cut-Off
ON
80C 176F
DEC
Ext.Temp
26C
DEC
- 25 -
BREAK DOWN
BATTERY VOLTAGE
CELL LOW VOL
BATTERY VOLTAGE
CELL HIGH VOL
CONTROL FAILURE
BATTERY CHECK
LOW VOLTAGE
BATTERY CHECK
HIGH VOLTAGE
- 26 -
SPECIFICATIONS
SPECIFICATIONS
AC Input: 100-240V (100W-90W)
DC Input: 11-18V
Circuit Power: Max. Charge Power 80W
Max. Discharge Power 10W
Charge Current Range: 0.1-6.0A
Discharge Current Range: 0.1-2.0A
Current Drain For Balancing LiPo: 300mA/cell
NiCd/NiMH Battery Cell Count: 1-15Cells
LiPo/LiFe/Lilon Cell Count: 1-6Cells
Pb battery voltage: 2-20V
Net Weight: 490g
Dimension: 135x112x60.9mm
SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE.
Manufactured by
SKYRC TECHNOLOGY CO., LTD.
www.skyrc.com
- 27 -