Anda di halaman 1dari 11

Series

Mammography X-ray System

Service Manual

Section 2.
Technical Document
of the
MX-600

Diagnostic Mammography X-ray System

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

Table of Contents

1. Single Load Ratings IEC 60613.....

2. Focus and tolerance between the focus and datum axis...

3. The attenuation of X-ray beam...

4. The location of focus mark .....

5. X-ray tube teat data ...

6. The limit of X-ray tube temperature .

10

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

1. Single Load Ratings IEC 60613

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

2. Focus and tolerance between the focus and datum axis.

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

3. The attenuation of X-ray beam.


1. Measurement at Non-attenuation

X-Ray

xxx R/min

2. Measurement at 0.3mmAl

O.3mmAl
X-Ray
xxx R/min

Measurement equipment
:Radiation Detector

3. Measurement at Bucky(Grid + FRP)

Grid
X-Ray
xxx R/min

Bucky

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

4. Measurement data
( At 30kV, 20mAs, Large focus)
Item
1st mR
Non-attenuation
15.28
0.3mmAl
8.29
Bucky(with Grid)
8.94

2nd mR
15.45
8.30
8.83

3rd mR
15.33
8.30
8.96

Avr. mR
15.35
8.30
8.91

%
100
54
58

Standard
Pass

- Blank -

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

4. The location of focus mark

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

5. X-ray tube Test data


PURPOSE : To verify housing/unit integrity under simulated catastrophic conditions.
The T/U will be ran at a power level that will bring the housing to thermal
equilibrium @ 80C for 10 minutes, following this the T/U power will be increased to obtain
100% heat storage for addition 2 min.
< Over pressure test>

RADIEQ CO., LTD.

MX-600

Series

Mammography X-ray System

Service Manual

6. The limit of X-ray tube temperature.


- Max. Temperature shutdown Test
PURPOSE : To verify that safety devices on the unit are functioning properly during an
over temperature / pressure condition.
Temperature rating of thermal cutoff : 80C
Thermocouple location : Center of housing
: The thermocouple is actually rated at 79.4C 3.9C. The thermocouple is inside the
housing and connected in series with the common leg of the SRATOR. See attached and
data.

RADIEQ CO., LTD.

MX-600

10

Grove
Cassette
Radiography
Enlargement
Filter
Irradiation
Detector
Guide
Patient
Cassette
Fig.
2-3
2-9plate
2-19
2-18
2-17
2-16
2-15
2-14
2-13
2-12
2-11
2-10
2-8
2-7
2-6
2-5
2-1
Radiograp
Foot Switch
Model:
SHIELDPart No: Part
No.:
SPOT
18X24
MASK
222-U542-000
222-U540-000
222-U541-000
PADDLE
Model:
Model:
MAG.
PADDLE
PADDLE
19
18FACE
16 222-U550-000
18X24
24X30
Mode:24X30
15
14
17
table
fixing
selection
lever
radiography
holder
field
limiting
9 BUCKY
8
7
guide
plate
movement
attachment
hy
Table
table
X-RAY TUBE
/ HOUSING
222-U532-000
10X14cm
18X24cm
24X30cm
Part
No.:
222-U530-000
222-U533-000
222-U531-000
CAUTION:
THIS
PATENT
BE ALWAYS
X-ray
FieldNo.:
Size:
SID:GURD SHOULD
60 cm
222-U510-000
222-U511-000
Part
release
plate
section
table
rail
knob lever ATTACHED EXCEPT MAGNIFICATION MODE
X-ray
Field
Size:
18X24
24X30
Max.
comprssion
force:
240N cm
Mammography X-ray System
Series
(center
SID:
60 cm
WARNING
Way of insertion
and
both
This
X-ray unit may be dangerous
Service
Manual
DENSITY
mAs
k
V
Model: MAG. SPOT PADDLE to patient and operator unless safe
sides)
exposure factors and operating
INHIBIT

FILM
SPEED

MAGNIFY

CONTROL PANEL

MODEL NO. : MXR-200


SERIAL NO. :

Momentaly : 25 A
Longe time : 3.5 A

Manufacturer
MedisonAcoma Co., Ltd.
22-8. 3-CHOME, HONGO
BUNKYO-KU TOKYO JAPAN

CN7

RADIEQ CO., LTD.

CPU OUT

CPU INT.

Manufacturer
MedisonAcoma Co., Ltd.

CN7

CN6

Momentaly : 25 A
Longe time : 3.5 A

CN8

CN5

Voltage : 230V
Phase : 1
Frequency : 50/60Hz

Control Panel

CN1

22-8. 3-CHOME, HONGO


BUNKYO-KU TOKYO JAPAN

CN10

AC 13V
AC 32V
AC 100V
DC+5V
DC+12V
DC-12V
DC+24V

AC 230V

Circuit
Braker

Sub-power
circuit

INPUT POWER

CPU Board

Caution : Do not touch this part

X-ray exposure inhibit

CN2

CN8

CN10 CN9

CN1

INVERTER
Control Signal

AEC Detector Signal

Control Box

RADIOGRAPHY STAND

MODEL NO. : MXR-200


SERIAL NO. :

INPUT POWER

Fig. 2-2 Overall BLOCK DIAGRAM

22-8. 3-CHOME, HONGO


BUNKYO-KU TOKYO JAPAN

Foot switch for Magnet

CN1

Manufacturer
MedisonAcoma Co., Ltd.

Foot switch to compres

Voltage : 230V
Phase : 1
Frequency : 50/60Hz

MODEL NO. : MXR-200


SERIAL NO. :

I/F Signal

10

INPUT POWER

CN3

Driving out

BOX
-CONTROL
+

ON/OFF Signal for vertical magnet

DENSITY

22-8. 3-CHOME, HONGO


BUNKYO-KU TOKYO JAPAN

I/F BOARD

CN3

This X-ray unit may be dangerous


to patient and operator unless safe
exposure factors and operating
instructions are observed.

TB4

TB1

mAs

CN1

High Frequency
DC/AC Inverter

High Voltage
Generator

AC/DC Converter

<Max. Temperature shutdown>

Manufacturer
MedisonAcoma Co., Ltd.

RELEASE

WARNING

13
12
11

MODEL NO. : MXR-200


SERIAL NO. :

TB1

0.5mm Al

CN1

1676 SOUTH PIONEER ROAD


SALT LAKE CITY UT 84104-4298

RELEASE

kV

INHIBIT

MAGNIFY

instructions
are ROTATIONAL
observed. C-ARM
+

0.03mm Mo
Max. comprssion force: 240N

TB1

BUKY

X-ray Exposure
HAND SWITCH

LOW

FILM
Manufacturer
MEDIUM
SPEED
VARIAN
MEDICAL
SYSTEMS
HIGH

CN2

RELEASE

INHIBIT

MAGNIFY

AEC DETECTOR

DENSITY
BACK UP

222-U534-000
-

BUKY

MODEL NO. : RAD-85S / B110


SERIAL NO. :
/
FOCUS :
0.1
0.3

BACK
UP

LOW
MEDIUM
HIGH

ROTOR BOARD

Part No.:

BUKY

CN2

Radiographic Stand
(C-arm)

mAs

kV

MO

BACK UP

ROTOR

BACK
UP

AL

LOW
MEDIUM
HIGH

FILM
SPEED

BACK UP

ANODE

BACK
UP

MO

FILAMENT
(Cathode)

AL

MO

X-ray Tube

AL

MX-600

11

Anda mungkin juga menyukai