devilbat
Page 1
Page 2
Page 3
Page 4
Page 5
1000
1250
1500
2000
mm
mm
mm
mm
36.In general, lay-out of motors and power outlets not exceeding a total of
_________ maybe included in the lighting lay-out provided such inclusion will
not make the reading, interpretation and/or checking of the said plan is
difficult.
A. 8
B. 10
C. 12
D. 14
37.What is the minimum insulation resistance of a buildings electrical wiring for
circuits using 2 sq. mm or 3.5 sq. mm conductors?
A. 100,000 ohms
B. 250,000 ohms
C. 350,000 ohms
D. 500,000 ohms
38.Supports of AC cable should have intervals not exceeding:
A. 1000 mm
B. 1200 mm
C. 1400 mm
D. 1500 mm
39.All energized part of electrical equipment operating at __________ or more
shall be guarded accidental contacts by approved enclosure.
A. 30 volts
B. 40 volts
C. 50 volts
D. 60 volts
40.Equipment rated 1,200 A or more and measuring more than 1,900 mm wide,
containing overcurrent devices, shall have an entrance at both ends of the
switchboard room. What must be the width and height of each entrance?
A. 800 mm wide x 2000 mm high
B. 800 mm wide x 2200 mm high
C. 600 mm wide x 2000 mm high
D. 600 mm wide x 2200 mm high
devilbat
Page 6
46.What refers to the underground service conductors between the street main,
including any risers at the pole or other structure or from transformer and the
first point of connection to the service entrance conductors in a terminal box?
The point of connection is considered to be the point of entrance of the
service conductors into the building.
A. Service entry
devilbat
Page 7
What is the
50.Wires on cables used on dry and wet locations for over 2000 volts insulation
and ozone resistant with moisture and resistant rubber and has a maximum
operating temperature of 90 deg C is _________ type.
A. MI
B. RHW
C. THW
D. THHN
devilbat
Page 8