Bosch Rexroth AG
A2FM Series 6
RE 91001/06.2012
501)
14
2230
83
23.5
45
U T1
335
32
198
128
18
T2
28
83
48
171
36
102
280 -0.081
26
30
128
MA (MB)
335
320
350
Flange
ISO 3019-2
Detail Y
250
245
M20x2.52)3)
60+0.011
+0.030
MB
Key
width 18
MA
70
64
70
M20x2.52)3)
79.4
36.6
Drive shafts
40
71
105
120
82
Ports
Designation Port for
Standard
Size3)
Maximum pressure
[bar]4 )
State8)
A, B
Service line
Fastening thread A/B
SAE J5185)
DIN 13
1 1/2 in
M16 x 2; 21 deep
400
T1
Drain line
DIN 38527)
M33 x 2; 18 deep
O6)
T2
Drain line
DIN 38527)
M33 x 2; 18 deep
X6)
38527)
400
Bearing flushing
DIN
MA, M B
DIN 38527)
1)
2)
3)
4)
5)
6)
7)
8)
To shaft collar
Center bore according to DIN 332 (thread according to DIN 13)
Observe the general instructions on page 46 for the maximum tightening torques.
Momentary pressure spikes may occur depending on the application. Keep this in mind when selecting measuring devices and
fittings.
Only dimensions according to SAE J518, metric fastening thread is a deviation from standard.
Depending on installation position, T1 or T2 must be connected (see also installation instructions on page 44).
The spot face can be deeper than specified in the appropriate standard.
O = Must be connected (plugged on delivery)
X = Plugged (in normal operation)