• Remove the screws on the back panel holding the control panel in place. See
Figure 1.
• Remove the control panel by sliding it forward (towards the front of the
stove). This will be tight and a rubber mallet might be needed.
• Mark and disconnect the ribbon cable from the panel and set the panel to the side.
• Remove the side panels by removing the screw at the top.
• Remove the wrap from the front of the stove (two screws on each side,
inside the side panels). See Figure 1.
• Drill out the rivets holding the hood to the stove frame.
Three rivets near the back of the stove frame (under side profile). See
Figure 1.
Three rivets on the back panel. See Figure 1
Three rivets inside the hopper. See Figures 3 & 4.
One rivet under the hood (if applicable). See Figure 2.
• Remove the hood.
• Install new hood. If needed remove the louvers from the old hood and attach them to
the new hood.
• Using the rivets included in the kit, install the hood.
• Install the control panel, connecting the ribbon cable to the panel first. Be sure to
connect the ribbon cable in the same orientation as it can off.
• Install the screws on the back of the stove to anchor the control panel.
10/2007
DWG. NO. 4000270 Rev B
Remove rivet
under hood
Figure 2 Figure 4