MONTHLY TEST
12)
Which of the following pencil lead is softest
(a) 7B (b) 6B (c) 5B (d) 4B
13) Which type of pencil produces lines of uniform width without
sharpening
(a) HB pencil (b) B pencil (c) automatic pencil (d) 2H pencil
14)
(a) 1500 x 1000 x 25 (b) 1000 x 700 x 25 (c) 700 x 500 x 25 (d) 500
x 350 x 15
15)
(a) less than 90 degree (b) equal to 90 degree (c) more than 90 &
less than 180 degrees (d) more than 180 & less than 360 degrees.
16)
(a) Less than 180 degrees (b) equal to 180 degrees (c) less than 360
degrees
(d) equal to 360 degrees.
17)
(a) Parallel line (b) Inclined line (c) Horizontal line (d) Vertical line.
19)
The lines which are with same distance between them and
they do not meet when extended are called
(a) Straight line (b) Parallel line (c) Perpendicular line (d) Inclined
line.
20)
A triangle has all the three sides are unequal in length and
three angles are unequal is called
(a) Equilateral triangle (b) Isosceles triangle (c) Right angle triangle
(d) Scalene triangle.
MONTHLY TEST
MONTHLY TEST
MARKS: 20
(a) Start winding (b) run winding (c) start capacitor (d) none of these
10)
(a) In series with run winding (b) in series with start winding (c) in parallel
with start winding (d) In parallel with run winding.
11)
(a) Moving iron (b) moving coil (c) moving coil with built in rectifier (d) electro
dynamic
14) The Unit of the power is
(a) Volt (b) ampere (c) Ohm (d) watt
15) The unit of energy is
``
(a) Watt/hr. (b) K.W/hr. (c) Ampere/hr. (d) Both (a) & (b)
16) VOM meter stands for
(a) Volt meter (b) ohm meter (c) multimeter (d) megger
17) One kilo ohm equals
(a) 102 (b) 103 (c) 106 (d) 1012
18) Coulomb is the unit of
(a) Charge (b) capacitance (c) reactance (d) impedance.
19) Watt meter records
(a) Apparent power (b) Normal power (c) True power (d) High power.
20) One Farad is equals
(a) 106F (b) 10-6F (c) 1012F (d) 109F
MONTHLY TEST
MARKS: 20
11)
(a) 1.033 kg/cm2 (b) 14.7 PSI (c) 1.022 kg/cm2 (d) 1.033 Bar
12)
1 Metric HP is equals
(a) 746 watts (b) 0.746 kW (c) 735.5 watts (d) 740 watts
14)
(a) Latent heat (b) super heat (c) latent heat of fusion (d) sensible heat
15)
(a) CHU (b) calorie (c) kilo calorie (d) both (b) and (c)
18)
(a) Solids (b) liquids (c) gases (d) both (b) and (c)
20)
According to Boyles law volume of given mass of gas varies________
to its pressure
(a) Inversely (b) directly (c) equally (d) none of these.
MONTHLY TEST
1) Triangle is a closed plane figure having three sides and three angles. The
sum of the three angles is always equals to_________ degrees.
(a) 360 (b) 270 (c) 180 (d) 90
2) Triangle having one angle of 90 degrees is called_______ triangle.
(a) Isosceles (b) right angle (c) left angle (d) equilateral
3) A triangle has all the three sides are unequal in length and also three
angles are unequal
(a) Equilateral (b) isosceles (c) right angle (d) scalene
4) Name the triangle having two sides of its sides are equal
(a) Equilateral (b) right angle (c) scalene (d) isosceles triangle.
5) Quadrilaterals are bound by______ angles and _______ sides
(a) 3 (b) 5 (c) 4 (d) 6
6) The sum of the four angles in a quadrilateral is equal to ______ degrees
(a) 320 (b) 270 (c) 360 (d) 180
7) Name the quadrilateral in which opposite sides are parallel and equal and
angles are not at right angles.
(a) Trapezium (b) trapezoid (c) rhombus (d) parallelogram.
8) Which among the following figure the diagonals cut each other and at 90
degrees
(a) Square/rhombus (b) rectangle (c) parallelogram/rhomboid (d) trapezoid
9) Two opposite sides are equal and parallel and four angles are right angles
are called as_____
(a) Trapezium (b) square (c) parallelogram (d) rectangle.
10)
20)
When two or more circles are drawing having common centre, they
are called
(a) Eccentric circle (b) cone (c) conic circle (d) Concentric circle.
MONTHLY TEST
MARKS: 20
(a) CHU (b) calorie (c) kilo calorie (d) both (b) and (c)
8) -20 degrees Celsius is equals to_______ degrees Fahrenheit
(a) 4 (b) -4 (c) -10 (d) none of these
9) Convection process of heat transfer method takes place in
(a) Solids (b) liquids (c) gases (d) both (b) and (c)
10)
According to Boyles law volume of given mass of gas varies________
to its pressure
(b) Inversely (b) directly (c) equally (d) none of these.
11)
(a) Extrinsic material (b) Intrinsic material (c) P type material (d) N type
material
12)
The process of adding impurities to an intrinsic semiconductor
material is called
(a) Duping (b) Deeping (c) doping (d) dipping
13)
(a) High resistance (b) more than 100 resistance (c) less than 100
resistance (d) zero resistance
14)
(a) 0.3 volts (b) 0.2 volts (c) 0.5 volts (d) 0.7 volts
16)
(a).7 volts (b) 0.3 volts (c) 0.1 volt (d) 0.5 volts
17)
(a) Rectification (b) voltage regulation (c) signal detection (d) switching
purpose
18)
(a) Laser emitting diode (b) light emitting diode (c) lamp emitting diode (d)
less emission diode
19)
MERIT TEST
7) Triangle is a closed plane figure having three sides and three angles. The
sum of the three
equals to_________ degrees.
angle is always
Name the triangle having two sides of its sides are equal
(a) Equilateral (b) right angle (c) scalene (d) isosceles triangle.
11)
Quadrilaterals are bound by______ angles and _______ sides
(a) 3 (b) 5 (c) 4 (d) 6
12)
The sum of the four angles in a quadrilateral is equal to ______
degrees
(a) 320 (b) 270 (c) 360 (d) 180
13)
Name the quadrilateral in which opposite sides are parallel and
equal and angles are not at right angles.
(a) Trapezium (b) trapezoid (c) rhombus (d) parallelogram.
14)
Which among the following figure the diagonals cut each other and
at 90 degrees
(a) Square/rhombus (b) rectangle (c) parallelogram/rhomboid (d) trapezoid
15)
Two opposite sides are equal and parallel and four angles are right
angles are called as_____
(a) Trapezium (b) square (c) parallelogram (d) rectangle.
16)
The edge of the drawing board on which T-square is made to
slide is called
(a) Working edge (b) Straight edge (c) Chisel edge (d) Battens
17)
18)
(a) Vertical and horizontal edge (b) stock and blade (c) straight and
cross edge
(d) two parallel edges.
19)
For lettering, general line work, object lines, sketching,
suitable grade of pencil are
(a) 2H or 3H (b) HB (c) H (d) H & 2H
20)
23)
For drawing thin lines of uniform thickness the pencil should
be sharpened in the form of
(a) Chisel edge (b) conical point (c) sharp edge (d) blunt edge
24)
MERIT TEST
TIME: 3Hrs.
(A) Current (B) EMF (C) PD (D) both (B) and (C)
5) A coarse tooth saw has_________ TPI
(A) 18 (B) 24 (C) 10 (D) 14
6) Current flowing in a closed circuit is 6 amperes and applied voltage is 230
volts. The resistance of the circuit is
(A) 38.33 (B) 83.33 (C) 28.33 (D) 35
7) I2 X R is the formula used for calculating__________
(A) Voltage (B) Energy (C) Power (D) power factor
8) An electrical installation of a house consists of 3 lighting points of 100 watts,
3 fan points of 60 watts and all light and fans are used for 4 hours per day,
the total energy consumed during the month of January is_______ units
(A) 59.52 (B) 58 (C) 50.52 (D) 25
9) 1000 X CS
11)
One inch is =
(A)24.05mm (B) 10mm (C) 25.4mm (D) 2.54mm
12)
The instrument used for measuring the current in a circuit without any
interruption is called
(A) Ammeter (B) Clamp-on-meter (C) Megger (D) mille ammeter
13)
(A) High carbon steel (B) High speed steel (C) High grade steel (D) Grey cast
iron
15)
(A) Steel (B) cast iron (C) Hardened steel (D) stainless steel.
17)
(A) High carbon steel (B) High speed steel (C) Both (A) & (B) (D) Tool steel
18)
(A) V =I X R (B) I = V/R (C) R = V/I (D) Both (A), (B) & (C)
19)
Solder is an alloy of
(A) Lead and copper (B) lead and zinc (C) lead and silver (D) Lead and tin
20)
(A) Controlling the gas (B) to close the gas line (C) to get required working
pressure (D) to avoid leakage.
22)
(A) Thin metal (B) Thick metal (C) both (A) & (B) (D) Hard metal
23)
In poly phase system the phase angle between the phases is_________
degrees
(A) 180 (B) 120 (C) 360 (D) 90
24)
(A) Line voltage (B) line voltage (C) 1/3 line voltage (D) line voltage
25)
(A) Starting the motor (B) controlling the motor (C) controlling the starting
current
(D) controlling the voltage.
26)
(A) Brown, black & black (B) Brown, black & silver (C) Brown, black & gold (D)
Brown, red & black
27)
Unit of capacitance is
(A) Coulomb (B) Farad (C) Micro farad (D) both (B) & (C)
28)
is equals________
MERIT TEST
TIME: 3Hrs
11)
12)
13)
14)
15)
16)
In poly phase system the phase angle between the phases is_________
degrees
(A) 180 (B) 120 (C) 360 (D) 90
17)
18)
19)
20)
21)
22)
23)
Current flowing in a closed circuit is 6 amperes and applied voltage is 230
volts. The resistance of the circuit is
(A) 38.33 (B) 83.33 (C) 28.33 (D) 35
24)
25)
An electrical installation of a house consists of 3 lighting points of 100 watts,
3 fan points of 60 watts and all light and fans are used for 4 hours per day, the
total energy consumed during the month of January is_______ units
(A) 59.52 (B) 58 (C) 50.52 (D) 25
26)
1000 X CS
(A) Starting the motor (B) controlling the motor (C) controlling the starting
current
(D) controlling the voltage.
29)
(A) Brown, black & black (B) Brown, black & silver (C) Brown, black & gold (D)
Brown, red & black
30)
Unit of capacitance is
(A) Coulomb (B) Farad (C) Micro farad (D) both (B) & (C)
31)
is equals________