1. Figure 1 shows a transconductance amplifier whose output is fed back to its input.
Find the input resistance Rm of the resulting one-port network. (Hint: Apply a test
voltage vx between the two input terminals, and find the current ix drawn from the
source. Then, Rin = vx/ix.).
vi Ri gmvi
Usi Usi
ng ng
the the
Bo Bo
de de Figure 1
Rin
plo plo
2. Figure 2 shows a signal sourcetsconnected ts to the input of an amplifier. Here Rs is the
source resistance, and Rt and Cfori are theforinput resistance and input capacitance,
respectively, of the amplifier. Derive
lo
anloexpression for Vi(s)/Vs(s), and show that it is
of the low-pass STC type. Find the 3-dB frequency for the case Rs = 20 kilo ohm, Rj =
w- w-
80 kilo ohm, and Ci = 5 pF.
pas pas
s s
an an
d d
hig hig
h- h-
pas pas
s s
ST ST
Figure 2
C C
3. Measurement of the frequency netresponse
net of an amplifier yields the data in the
following table: - -
f(Hz) 10 102 103 104 105 106 107
|T|(dB) 0 20 37 wo 40 wo 37 20 0
Provide approximate plausible values
rks forrksthe missing table entries. Also, sketch and
clearly label the magnitude frequency
(Fi
response
(Fi
(Bode plot) of this amplifier.
gs. gs.
1.2 1.2
3 3
an an
4. A voltage amplifier has the transfer function
100
= 10 2
1+ 1+
10 4
Using the Bode plots for low-pass and high-pass STC networks, sketch a Bode plot
for |Av|. Give approximate values for the gain magnitude at f = 10 Hz, 102 Hz, 103
Hz, 104 Hz, 105Hz, 106 Hz, and 107 Hz. Find the bandwidth of the amplifier (defined
as the frequency range over which the gain remains within 3 dB of the maximum
value).
=
+ +1
And
=
+[ ]
+1
Figure 3
Figure 4