hkedown Guide
MADE EASY
Clean your o\ryngun with confidence.
Savesyou moneyon repairs!
ilililrui
WinchesterI90
Similar Models
Winchester290 Winchester 290 Deluxe Winchester 150 & 190 Lever Action Rifle
24 t22
sd \16
70 .45
36 .25
lb
38
,a @42
2 A r4o
28 39
41'
72
E, 71\ 29<
27
154
sd/'
31
9. Drifting out the small, short crosspin in the magazinetube hangernear the muzzle will
releasethe outer magazinetube for removaltoward the front" This will allow the forend to
be takenoff downward. After removalof the forend,the nylon forend mount is easily slid
out of its dovetailtowardeitherside(makea smallmark("L") on the left sidefor reassem-
blv).
17. Pushthehammer
pivot out towardeithersideandremovethehammerassem-
bly upward. Thehammerspringandits two nylon supporl
piecesareeasilyremovedfrom thehammer.
A
left with the groovesup so the hammerspringtail on the right
lies in the srooveon the safetv.
ReadSteps#20-#24beforebeginning.
20.Thetop pin retainsthe carrierlever. Drift it out towards
the right. The carrierleveris not removedat this time.
21. Theroll pin canbe drifted out eitherway. Onceit passesthe
springandplunger;restrainthe springandplungerwith a tool and
drift it out the rest of the wav.
thehousinsR.n:l:i?ilffiTliJi?ir'.','d;:iTl"fr
Reassembly
Tips:
Note that the hammerpivot has one flat side. Be sureboth of the
nylon hammer spring supportsare oriented so that their flat sides
line up with the flat surfaceon the pin. Do not force the pin through
or damagewill occur to the nylon bushings.
When replacing the sear/disconnector
assemblybe sure the lower end of the sear
spring goestoward the rear, down the
slope of the trigger.
When driving the firing pin stop pin on the left side of the bolt, the extractor pivot pin may
fall out. Insert the bolt handle temporarily to stop this.
When replacing the bolt spring and guide, use a small screwdriver to push in the spring in
small increments,while keeping pressureon the plunger. When the rear tip of the plunger is
in the spring hole, restrainthe plunger with a fingertip while inserting the bolt and then the
bolt handle. Be sure the plunger restsin the recessof the bolt correctly.