D
LA
Question asked (396):
When reeving a new wire onto a self-stowing winch drum you should, after looking at
brake arrangement, reeve it to pay out as follows:
Selected answer (score 0):
Don't know
Correct answer:
Direction B
On the figure there are four (4) possible directions, shown by the arrowed lines, which
could be the correct direction associated with the term "HEAD LINE". Which one is the
correct one?
Selected answer (score 0):
AR
Don't know
Correct answer:
Head line is given by B on the figure
Page 1/11
Wrong answer summary
D
Starboard quarter is given by C on the figure
LA
Question asked (614):
What is the normal name of the special wire/rope on board the ship used to make a tug
fast?
Selected answer (score 0):
Don't know
Correct answer:
Towing spring
When acting as helmsman would you expect the reading of the gyro compass to be the
same as the magnetic compass?
Selected answer (score 0):
Don't know
Correct answer:
AR
Page 2/11
Wrong answer summary
D
The Aft Breast Line is B, in the figure
LA
What letter indicates the direction "AHEAD", in the figure?
Selected answer (score 0):
Don't know
Correct answer:
Ahead is indicated by A, in the figure
Don't know
Correct answer:
Raise the fire alarm.
Page 3/11
Wrong answer summary
D
Correct answer:
Fog signal of one long blast heard on the port bow at regular intervals of about 2 minutes
LA
Question asked (3947):
What will you do if you are helmsman and the OOW (officer on watch) gives you the
order: Starboard ten
Selected answer (score 0):
Don't know
Correct answer:
PA
Repeat the command back and then turn the wheel to make the rudder turn 10 degrees
to starboard of amidships
Correct answer:
A visual and audible alarm signal at the control panel
Page 4/11
Wrong answer summary
D
The fire is extinguished by avoiding the contact between the fuel vapours and the oxygen
LA
In order to extinguish a flammable liquid of the same kind as alcohol, we can use:
Selected answer (score 0):
Don't know
Correct answer:
Anti-alcohol foam
Correct answer:
Davit launched liferaft
Page 5/11
Wrong answer summary
D
2 sec
LA
Question asked (20291):
In which way shall a survivor be hauled out of the sea?
Selected answer (score 0):
Don't know
Correct answer:
Horizontal
stated
Don't know
Correct answer:
One in which the atmosphere may have a deficiency of oxygen or may have a toxic gas
Page 6/11
Wrong answer summary
D
Whenever the gangway is rigged between ship and shore.
LA
A lifejacket should be provided with:
Selected answer (score 0):
Don't know
Correct answer:
A whistle and a light
Don't know
Correct answer:
Do not touch any suspicious packages
AR
Correct answer:
The final coil loaded at the centre of the stow in second, third and fourth tiers
Page 7/11
Wrong answer summary
D
Sweep, saltwater wash, freshwater rinse, dry
LA
What must be ensured when using the ship's cargo gear on a General Cargo vessel in
hot climates?
Selected answer (score 0):
Don't know
Correct answer:
On a General Cargo Vessel, what must be ensured when using ship's cargo gear in hot
climates?
Selected answer (score 0):
G
Don't know
Correct answer:
That grease from wire falls does not fall onto cargoes being loaded or discharged
N
Don't know
Correct answer:
Stop the bunker operation
Page 8/11
Wrong answer summary
D
Because bilge sounding pipes could become blocked
LA
You have been assigned to enter a hold and check the general cargo stowed in it, as part
of an on-passage monitoring procedure. What must be in place before you can do that?
Selected answer (score 0):
Don't know
Correct answer:
What general background colour is used on warning signs that indicate emergency or first
-aid features, or indicate a safe condition?
Selected answer (score 0):
G
Don't know
Correct answer:
Green.
N
Don't know
Correct answer:
Secure the tug means: to make fast the tug
Page 9/11
Wrong answer summary
D
Bitter end means: the end link of an anchor cable that is secured within the chain locker
LA
Which of the following is false when a casualty is bleeding?
Selected answer (score 0):
Don't know
Correct answer:
Cover the wound with a cloth
Don't know
Correct answer:
Confirm that it won't form an emulsion
AR
Correct answer:
Sorbents
Page 10/11
Wrong answer summary
D
Identification and passes must checked and number of persons on board recorded
LA
Question asked (34488):
On a General Cargo Vessel cargo is be secured using turnbuckles (bottlescrews) and
wires; what is the minimum number of bulldog grips that should be used to attach wires to
turnbuckles ?
Selected answer (score 0):
Don't know
Correct answer:
A minimum of three
What are the more likely causes of damage to the cargo holds internal structure on a
General Cargo vessel?
Selected answer (score 0):
Don't know
AR
Correct answer:
Damage may be caused by fork lift truck operations and loading/discharge of heavy cargo
Cargo vessel?
Selected answer (score 0):
Don't know
Correct answer:
That all track ways are clear of obstructions
Page 11/11
Wrong answer summary
CES version: CES 5.2.8
Test date: 14.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: General cargo vessel
D
LA
Question asked (223):
When keeping a lookout, what would be the correct understanding of the question "What
is the aspect of the other ship"?
Selected answer (score 0):
Don't know
Correct answer:
PA
The question is requesting some indication of the direction the other ship is heading.
Direction B
What is name of the machine shown, used to heave on the ropes during mooring and
unmooring?
Selected answer (score 0):
Don't know
AR
Correct answer:
Winch
Page 1/11
Wrong answer summary
D
Blue
LA
Who is authorised to operate lifting equipment around the ship?
Selected answer (score 0):
Don't know
Correct answer:
Those ship's personnel who have been assessed as competent and are duly authorised
Page 2/11
Wrong answer summary
D
The Stern area is indicated by C, in the figure
LA
When acting as helmsman, what should be the method of responding to an order?
Selected answer (score 0):
Don't know
Correct answer:
When receiving an order, the order should be repeated back to the person who gave it
before carrying out the order.
A Gangway is a portable means of access between the ship and the shore
Page 3/11
Wrong answer summary
D
1 Smoking in bed. 2 Covering of electric fires with blankets. 3 Overloading electric plugs.
LA
Anyone of the crew who is assigned to watch duties in port has a number of important
tasks to carry out. Which one of the listed tasks should be included in the watchman's
duties?
Selected answer (score 0):
Don't know
Correct answer:
PA
Check the moorings for correct tightness and ensure the gangway remains safe and
secure.
Most EPIRBs are automatically activated when they enter the water
How will you act if you are helmsman and the OOW (officer on watch) gives you the
order: Nothing to port
Selected answer (score 0):
Don't know
AR
Correct answer:
Dont allow the ship to swing at all to port
Page 4/11
Wrong answer summary
D
a solid (cardboard or wood)
LA
Proteinic foams have the feature of being?
Selected answer (score 0):
Don't know
Correct answer:
Of low expansion, viscous and solid, easily contaminated by hydrocarbons
Don't know
Correct answer:
2 compartments
AR
Correct answer:
The weak link
Page 5/11
Wrong answer summary
D
perform all duties associated with abandonment, assist others and operate a rescue boat
LA
You have abandoned ship in a liferaft. In most cases, which of the following actions
should you generally take?
Selected answer (score 0):
Don't know
Correct answer:
anchor
When it is fitted with a guard or similar device which prevents foreseeable contact
between a person, his clothing or items held in his hands, whilst it is in operation
Page 6/11
Wrong answer summary
D
Cold work permit + Permit for entry .
LA
One of the checks during the annual Class survey of the UMS functions is focusing on
cleanliness of the engine room. What is the reason for such a check ?
Selected answer (score 0):
Don't know
Correct answer:
To reduce the general risk of fire in an unmanned engine room.
Don't know
Correct answer:
Confirm with their search partner that the object found is suspicious.
Page 7/11
Wrong answer summary
D
With their cores aligned fore and aft
LA
When will a hatch cover cross-joint wedge need replacement on a General Cargo
Vessel?
Selected answer (score 0):
Don't know
Correct answer:
When the flat spring is missing
Don't know
Correct answer:
Cargo hold fan inlets near paint areas must be closed
Page 8/11
Wrong answer summary
D
Stop the bunker operation
LA
Question asked (33263):
What must be observed when checking cargo lashing belts on a General Cargo Vessel?
Selected answer (score 0):
Don't know
Correct answer:
That they are not torn
Correct answer:
The crew mess
Page 9/11
Wrong answer summary
D
Lifeboat drill
LA
An airway should be used when
Selected answer (score 0):
Don't know
Correct answer:
The patient is breathing on his own but is doing so with great difficulty
Don't know
Correct answer:
Inspect and detain ship that are not meeting the requirements until they are able to
demonstrate compliance with the regulations
AR
Correct answer:
Sorbents
Page 10/11
Wrong answer summary
D
Correct answer:
Overflowing ballast water running over side and onto quay resulting in possible damage
to shore equipment
LA
Question asked (34480):
On a General Cargo ship, what must completed before a cargo hoist wire is replaced on a
deck crane ?
Selected answer (score 0):
Don't know
Correct answer:
A full risk assessment carried out and a permit to work issued
PA
Question asked (34483):
Which of the following statements is the most appropriate with respect to cargo after
G
loading on a General Cargo Vessel?
Selected answer (score 0):
Don't know
Correct answer:
N
Don't know
Correct answer:
Only when clean and Chief Officer has approved use
When preparing to ballast the double-bottom tanks of a General Cargo Vessel, which of
the following must be done?
Selected answer (score 0):
Don't know
Correct answer:
The Chief Officer's ballast plan followed exactly
Page 11/11
Wrong answer summary
CES version: CES 5.2.8
Test date: 14.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: General cargo vessel
D
LA
Question asked (193):
When you join a new ship, how are you informed about safety rules, alarm instructions
and your own duties in case of an emergency?
Selected answer (score 0):
Don't know
Correct answer:
By muster lists exhibited in conspicuous places
On the figure there are four (4) possible definitions of the term "QUAY" given. Which one
is the correct one?
Selected answer (score 0):
Don't know
AR
Correct answer:
Quay is given by A on the figure
Page 1/11
Wrong answer summary
D
Throw a lifebuoy over board and report to the bridge immediately.
LA
When should the lookout report another vessel?
Selected answer (score 0):
Don't know
Correct answer:
As soon as it is sighted or heard.
Correct answer:
Portable bridge arrangement between ship and shore, when alongside.
Page 2/11
Wrong answer summary
D
Development of nitrous gases?
LA
Are there any restriction on entry into cargo holds at sea?
Selected answer (score 0):
Don't know
Correct answer:
Permission must be obtained from Chief Officer
Page 3/11
Wrong answer summary
D
The Mooring Buoy is indicated by B, in the figure
LA
What are the duties of the bridge lookout during the night, when the vessel is in the
middle of the ocean?
Selected answer (score 0):
Don't know
Correct answer:
In a smoke filled alleyway where will the cleanest air be found, and how should you
proceed out?
Selected answer (score 0):
Don't know
AR
Correct answer:
Near to the deck, crawl out keeping your face as near to the deck as possible.
tasks to carry out. Which one of the listed tasks should be included in the watchman's
duties?
Selected answer (score 0):
Don't know
Correct answer:
Check the moorings for correct tightness and ensure the gangway remains safe and
secure.
Page 4/11
Wrong answer summary
Correct answer:
Fog signal of one long blast heard on the port bow at regular intervals of about 2 minutes
D
Don't know
Correct answer:
Dont allow the ship to swing at all to port
LA
Question asked (3952):
Apart from steering the helmsman should also:
Selected answer (score 0):
Don't know
Correct answer:
Regularly check the gyro against the magnetic compass
PA
Question asked (10115):
The necessary elements to create fire are
G
Selected answer (score 0):
Don't know
Correct answer:
N
Correct answer:
O2: 21% N2: 78% H2O: traces CO2: traces, Rare gases: traces
Page 5/11
Wrong answer summary
D
The weak link
LA
Question asked (20209):
The wearer of a lifejacket can jump into the water without injury and without damaging the
jacket from a height of at least:
Selected answer (score 0):
Don't know
Correct answer:
4,50 m
Correct answer:
Horizontal
Page 6/11
Wrong answer summary
D
Whenever the gangway is rigged between ship and shore.
LA
How should the painter of a liferaft which is fitted with a hydrostatic release be secured to
the ship?
Selected answer (score 0):
Don't know
Correct answer:
Secured via a weak link to a secure part of the ship
Security Level 3
Don't know
Correct answer:
All alternatives
Page 7/11
Wrong answer summary
D
When the flat spring is missing
LA
Question asked (33250):
What is known as a "Non-Standardized Cargo" on a General Cargo Ship?
Selected answer (score 0):
Don't know
Correct answer:
Cargo which requires individual stowage and securing arrangements
Page 8/11
Wrong answer summary
D
The necessary permits, based on valid atmospheric and other applicable tests.
LA
Question asked (33693):
To conform with "best practise", can you drive a crane and stand-by for a colleague who
has entered a cargo tank at the same time?
Selected answer (score 0):
Don't know
Correct answer:
No.
of the ship.
Don't know
Correct answer:
Secure the tug means: to make fast the tug
Page 9/11
Wrong answer summary
D
The respiratory centre in the brain
LA
An airway should be used when
Selected answer (score 0):
Don't know
Correct answer:
The patient is breathing on his own but is doing so with great difficulty
Don't know
Correct answer:
All fire hydrants and sounding pipes must be accessible
Page 10/11
Wrong answer summary
D
All cargo must be fully secured before the vessel sails
LA
Question asked (34484):
On a General Cargo ship, when can dunnage from a previous cargo be used again for
cargo?
Selected answer (score 0):
Don't know
Correct answer:
Only when clean and Chief Officer has approved use
Correct answer:
The aft end of No. 4 hold
wires; what is the minimum number of bulldog grips that should be used to attach wires to
turnbuckles ?
Selected answer (score 0):
Don't know
Correct answer:
A minimum of three
Page 11/11
Wrong answer summary
CES version: CES 5.2.8
Test date: 14.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: General cargo vessel
D
LA
Question asked (516):
On the figure there are four (4) possible definitions of the term "BOLLARD" given. Which
one is the correct one?
Selected answer (score 0):
Don't know
Correct answer:
Bollard is given by D on the figure
On the figure there are four (4) possible definitions of the term "MIDSHIPS" given. Which
one is the correct one?
Selected answer (score 0):
Don't know
AR
Correct answer:
Midships is given by B on the figure
Page 1/11
Wrong answer summary
D
Practical exercise for the people on board to practice their duties and be prepared in the
case of an emergency abandon ship.
LA
Question asked (1491):
When acting as helmsman would you expect the reading of the gyro compass to be the
same as the magnetic compass?
Selected answer (score 0):
Don't know
Correct answer:
Very seldom would they be the same
As a general rule, where would you expect to find a portable fire extinguisher in any
space?
Selected answer (score 0):
Don't know
AR
Correct answer:
Near to the entrance to the space
Page 2/11
Wrong answer summary
D
CO2
LA
Having a CO2 alarm during normal working hours, what immediate action should be
taken?
Selected answer (score 0):
Don't know
Correct answer:
Get out of the engine room as soon as possible.
Don't know
Correct answer:
Breadth is indicated by B, in the figure
Page 3/11
Wrong answer summary
D
A tug assists the ships to moor and unmoor
LA
What is the meaning of the term "Make Fast", when mooring the ship?
Selected answer (score 0):
Don't know
Correct answer:
Make Fast means secure the ropes to the bits
Don't know
Correct answer:
Lifeboat
AR
Correct answer:
Use a rope ladder close to the raft to climb down and board
Page 4/11
Wrong answer summary
D
Ensuring that all persons avoid smoking in bed.
LA
Anyone of the crew who is assigned to watch duties in port has a number of important
tasks to carry out. Which one of the listed tasks should be included in the watchman's
duties?
Selected answer (score 0):
Don't know
Correct answer:
PA
Check the moorings for correct tightness and ensure the gangway remains safe and
secure.
Correct answer:
The lookout should state "Light 4 points to port"
IA
Page 5/11
Wrong answer summary
Correct answer:
By repeating the order
D
Don't know
Correct answer:
By smothering and also by providing some cooling
LA
Question asked (10231):
Which of the following may cause a fire in the accommodation spaces?
Selected answer (score 0):
Don't know
Correct answer:
All the mentioned alternatives
child's lifejacket
Page 6/11
Wrong answer summary
D
In the muster list.
LA
What safety clothing should be worn during an anchoring operation?
Selected answer (score 0):
Don't know
Correct answer:
All of the equipment mentioned in the alternative answers.
important?
Selected answer (score 0):
Don't know
Correct answer:
AR
Don't know
Correct answer:
"On SECURITY Level 1, 2 & 3"
Page 7/11
Wrong answer summary
D
From both sides of a cargo hold working towards the centre
LA
Question asked (33217):
Why are drains fitted to hatch coamings of a General Cargo ship?
Selected answer (score 0):
Don't know
Correct answer:
What prevents hatch cover panels from lifting in a seaway on a General Cargo vessel?
Selected answer (score 0):
Don't know
G
Correct answer:
The hatch cleats
N
Don't know
Correct answer:
Immediately inform the stevedore foreman and duty officer
Page 8/11
Wrong answer summary
D
Cargo which requires individual stowage and securing arrangements
LA
When lashing general cargoes why are short lashings preferred to long ones?
Selected answer (score 0):
Don't know
Correct answer:
Because they are more easily tightened and held in tension
Don't know
Correct answer:
Dunnage of 7.5cm x 7.5cm cross section should be laid athwartships over the tank top
about 3m apart
Page 9/11
Wrong answer summary
D
Let go the tug means: to cast off the lines that secure the tug to the ship
LA
What do you understand by: Let go the port anchor?
Selected answer (score 0):
Don't know
Correct answer:
Let go the port anchor means: open the port windlass brake
Don't know
Correct answer:
Different type of joints
AR
Correct answer:
Fractured spine
Page 10/11
Wrong answer summary
D
Low sulphur fuels reduce emissions of volatile organic compounds
LA
What will you do when all the fresh water in the survival craft is finished or about to finish?
Selected answer (score 0):
Don't know
Correct answer:
Start collecting rain water
Don't know
Correct answer:
Inform Chief Officer and prepare to change block if required
Page 11/11
Wrong answer summary
CES version: CES 5.2.8
Test date: 14.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: General cargo vessel
D
LA
Question asked (223):
When keeping a lookout, what would be the correct understanding of the question "What
is the aspect of the other ship"?
Selected answer (score 0):
Don't know
Correct answer:
PA
The question is requesting some indication of the direction the other ship is heading.
Direction B
What is name of the machine shown, used to heave on the ropes during mooring and
unmooring?
Selected answer (score 0):
Don't know
AR
Correct answer:
Winch
Page 1/11
Wrong answer summary
D
Blue
LA
Who is authorised to operate lifting equipment around the ship?
Selected answer (score 0):
Don't know
Correct answer:
Those ship's personnel who have been assessed as competent and are duly authorised
Page 2/11
Wrong answer summary
D
The Stern area is indicated by C, in the figure
LA
When acting as helmsman, what should be the method of responding to an order?
Selected answer (score 0):
Don't know
Correct answer:
When receiving an order, the order should be repeated back to the person who gave it
before carrying out the order.
A Gangway is a portable means of access between the ship and the shore
Page 3/11
Wrong answer summary
D
1 Smoking in bed. 2 Covering of electric fires with blankets. 3 Overloading electric plugs.
LA
Anyone of the crew who is assigned to watch duties in port has a number of important
tasks to carry out. Which one of the listed tasks should be included in the watchman's
duties?
Selected answer (score 0):
Don't know
Correct answer:
PA
Check the moorings for correct tightness and ensure the gangway remains safe and
secure.
Most EPIRBs are automatically activated when they enter the water
How will you act if you are helmsman and the OOW (officer on watch) gives you the
order: Nothing to port
Selected answer (score 0):
Don't know
AR
Correct answer:
Dont allow the ship to swing at all to port
Page 4/11
Wrong answer summary
D
a solid (cardboard or wood)
LA
Proteinic foams have the feature of being?
Selected answer (score 0):
Don't know
Correct answer:
Of low expansion, viscous and solid, easily contaminated by hydrocarbons
Don't know
Correct answer:
2 compartments
AR
Correct answer:
The weak link
Page 5/11
Wrong answer summary
D
perform all duties associated with abandonment, assist others and operate a rescue boat
LA
You have abandoned ship in a liferaft. In most cases, which of the following actions
should you generally take?
Selected answer (score 0):
Don't know
Correct answer:
anchor
When it is fitted with a guard or similar device which prevents foreseeable contact
between a person, his clothing or items held in his hands, whilst it is in operation
Page 6/11
Wrong answer summary
D
Cold work permit + Permit for entry .
LA
One of the checks during the annual Class survey of the UMS functions is focusing on
cleanliness of the engine room. What is the reason for such a check ?
Selected answer (score 0):
Don't know
Correct answer:
To reduce the general risk of fire in an unmanned engine room.
Don't know
Correct answer:
Confirm with their search partner that the object found is suspicious.
Page 7/11
Wrong answer summary
D
With their cores aligned fore and aft
LA
When will a hatch cover cross-joint wedge need replacement on a General Cargo
Vessel?
Selected answer (score 0):
Don't know
Correct answer:
When the flat spring is missing
Don't know
Correct answer:
Cargo hold fan inlets near paint areas must be closed
Page 8/11
Wrong answer summary
D
Stop the bunker operation
LA
Question asked (33263):
What must be observed when checking cargo lashing belts on a General Cargo Vessel?
Selected answer (score 0):
Don't know
Correct answer:
That they are not torn
Correct answer:
The crew mess
Page 9/11
Wrong answer summary
D
Lifeboat drill
LA
An airway should be used when
Selected answer (score 0):
Don't know
Correct answer:
The patient is breathing on his own but is doing so with great difficulty
Don't know
Correct answer:
Inspect and detain ship that are not meeting the requirements until they are able to
demonstrate compliance with the regulations
AR
Correct answer:
Sorbents
Page 10/11
Wrong answer summary
D
Correct answer:
Overflowing ballast water running over side and onto quay resulting in possible damage
to shore equipment
LA
Question asked (34480):
On a General Cargo ship, what must completed before a cargo hoist wire is replaced on a
deck crane ?
Selected answer (score 0):
Don't know
Correct answer:
A full risk assessment carried out and a permit to work issued
PA
Question asked (34483):
Which of the following statements is the most appropriate with respect to cargo after
G
loading on a General Cargo Vessel?
Selected answer (score 0):
Don't know
Correct answer:
N
Don't know
Correct answer:
Only when clean and Chief Officer has approved use
When preparing to ballast the double-bottom tanks of a General Cargo Vessel, which of
the following must be done?
Selected answer (score 0):
Don't know
Correct answer:
The Chief Officer's ballast plan followed exactly
Page 11/11
Wrong answer summary
CES version: CES 5.2.8
Test date: 14.03.2016
Test type: STCW
Department: Deck
Level: Support
Vessel type: General cargo vessel
D
LA
Question asked (396):
When reeving a new wire onto a self-stowing winch drum you should, after looking at
brake arrangement, reeve it to pay out as follows:
Selected answer (score 0):
Don't know
Correct answer:
Direction B
On the figure there are four (4) possible directions, shown by the arrowed lines, which
could be the correct direction associated with the term "HEAD LINE". Which one is the
correct one?
Selected answer (score 0):
AR
Don't know
Correct answer:
Head line is given by B on the figure
On the figure there are four (4) possible definitions of the term "AIR DRAUGHT" given.
Which one is the correct one?
Selected answer (score 0):
Don't know
Correct answer:
Air draught is given by D on the figure
Page 1/12
Wrong answer summary
D
Test the steering by putting the wheel hard over both ways
LA
Question asked (817):
"Overshoot" is an expression related to a ship's steering ability. What is the correct
understanding of this expression?
Selected answer (score 0):
Don't know
Correct answer:
rudder
What is the meaning of the abbreviation "SWL" as stamped on lifting gear around the
ship?
G
Selected answer (score 0):
Don't know
Correct answer:
N
What is the meaning of the term "Steady as she goes" when acting as helmsman?
Selected answer (score 0):
Don't know
AR
Correct answer:
While altering the ships head, the instruction "steady as she goes" means reduce the
ships swing as rapidly as possible and steady on present course
Page 2/12
Wrong answer summary
Correct answer:
The brake securely applied, all cement/covering into the chain locker and securing
arrangements from windlass removed. The guillotine can remain for removal when ready
D
Don't know
Correct answer:
Put on the life jacket
LA
Question asked (3592):
In the figure, which letter indicates what is known as "mooring bits"?
Selected answer (score 0):
Don't know
Correct answer:
The mooring bits are indicated by D, in the figure
PA
Question asked (3600):
Where is the "FORECASTLE", in the figure?
G
Selected answer (score 0):
Don't know
Correct answer:
N
Don't know
Correct answer:
The bits for the Forward Spring is indicated by D, in the figure
What is the output shown on the "Rate of Turn" display fitted on the bridge?
Selected answer (score 0):
Don't know
Correct answer:
The Rate of Turn indicator displays the rate the ship is swinging in degrees per minute
Page 3/12
Wrong answer summary
D
All of the mentioned equipment.
LA
Which of the following actions will most effectively prevent fire in a cabin?
Selected answer (score 0):
Don't know
Correct answer:
Ensuring that all persons avoid smoking in bed.
Don't know
Correct answer:
Repeat the command back and then turn the wheel to make the rudder turn 10 degrees
to starboard of amidships
Page 4/12
Wrong answer summary
D
Conduction, convection and radiation
LA
According to European standards (E.N.) fire can be classified
Selected answer (score 0):
Don't know
Correct answer:
A, B,C,D
should be taken?
Selected answer (score 0):
Don't know
Correct answer:
AR
Close the valves on both bottles, first the acetylene and then the oxygen bottle
Don't know
Correct answer:
Fire main with fire valves
Page 5/12
Wrong answer summary
D
Lifebuoy with light
LA
An immersion suit is:
Selected answer (score 0):
Don't know
Correct answer:
Not allowing undue ingress of water after a jump from a heoght of not less than 4.5 m into
the water
anchor
How many hand held distress flares are carried in each liferaft with SOLAS A pack?
Selected answer (score 0):
Don't know
AR
Correct answer:
6
Page 6/12
Wrong answer summary
D
Whenever the gangway is rigged between ship and shore.
LA
Which of the following ear protection devices is most effective?
Selected answer (score 0):
Don't know
Correct answer:
Ear muffs
Don't know
Correct answer:
Security Level 3
AR
Correct answer:
Voyage itinerary and departure and arrival times.
Page 7/12
Wrong answer summary
D
With their cores aligned fore and aft
LA
How should steel coils be loaded at the start of cargo operations on a General Cargo
Vessel?
Selected answer (score 0):
Don't know
Correct answer:
From both sides of a cargo hold working towards the centre
Correct answer:
In recesses below manhole covers
Page 8/12
Wrong answer summary
D
Upright
LA
Question asked (33264):
Why should cargo residues be removed from bilge wells on a General Cargo vessel?
Selected answer (score 0):
Don't know
Correct answer:
Because bilge sounding pipes could become blocked
Correct answer:
To secure a rope
Page 9/12
Wrong answer summary
D
Let go the port anchor means: open the port windlass brake
LA
In the human body, breathing is controlled by
Selected answer (score 0):
Don't know
Correct answer:
The respiratory centre in the brain
Don't know
Correct answer:
Prominently marked and easily accessible
AR
Correct answer:
Confirm that it won't form an emulsion
Page 10/12
Wrong answer summary
D
Correct answer:
Overflowing ballast water running over side and onto quay resulting in possible damage
to shore equipment
LA
Question asked (34481):
What must be done before dock workers and stevedores are allowed on board a General
Cargo vessel?
Selected answer (score 0):
Don't know
Correct answer:
PA
Identification and passes must checked and number of persons on board recorded
Page 11/12
Wrong answer summary
Correct answer:
Damage may be caused by fork lift truck operations and loading/discharge of heavy cargo
D
LA
PA
G
N
IA
AR
M
Page 12/12