Take EACH stock firmware file(s) and place ALL these (without the folder they ar
e in), into SAME folder as these instructions i.e the the Easy Installer folder
How to Use
1] ALL needed files are in the zip file you downloaded except the FIRMWARE stock
ROM files
2] Install Motorola device manager 2.5.4.exe for correct Usb drivers (choose rep
air if already installed) and install minimal ADB /fastboot v 1.31.exe
3] plug in Usb cable and PUT phone into AP Fastboot Flash mode
4] by holding power and volume down ( - ) until phone powers off to blank screen
(may vibrate)
5] still holding both buttons count 1,2,3,4,5 and release both same time
6] Hopefully you should be in AP Fastboot Flash mode with USb cable plugged in?
7] if No go back to step [3] if YES continue
8] do not select anything on phone or press any more phone buttons - All done vi
a pc now
--------------------------------------------------------------------------------
--------
9] Now run the Easyinstaller.bat file and watch both pc screen and phone screen
for further instructions
10] Do not unplug USB cable until phone reboots and remember it take 5 to 10+ mi
ns to set up
so might seem stuck after boot animation... this is normal.