Parts Catalog
DGDA
DGDB
GENERATOR SET
Introduction
This catalog applies to the standard generator models DGDA and DGDB as listed in the Generator Set Data
Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference num-
ber corresponding to the same reference number in the parts list. Parts illustrations are typical. Unless other-
wise mentioned in the description or page heading, parts are interchangeable between models. Throughout
this catalog left and right sides are determined by facing the engine end (front) of the set.
Engine parts that have been modified or added by Onan are identified in this catalog. All other engine replace-
ment parts must be ordered from the engine manufacturer by referring to the engine manufacturers name-
plate and supplying all available information. Contact your nearest engine parts distributor for assistance in
ordering replacement parts.
Replacement Engine
Onan/Cummins Cummins
Generator Model Engine Model
1
Actuator, Electronic Governor, 25 Bracket, Mounting Watts Transducer, 69
Adapter, Exhaust, 26 Bracket, Retainer Battery, 37
Adapter, Generator, 49 Breaker, Circuit AC - AC Control Door, 70
Adapter, Generator Stator, 49 Breaker, Circuit AC - Fuel Tank Control, 22
Alarm, Audible, 68 Breaker, Circuit DC - Fuel Tank Control, 22
Alarm, Bell Circuit Breaker NonUL Approved, 77 Breaker, Circuit NonUL Approved, 77
Alarm, Common, 62 Breaker, Circuit UL Approved, 79
Alarm, Low Fuel, 9 Bulb, Replacement Emergency Stop Switch, 74
Alternator, Engine, 39
Cable, Battery, 7
Ammeter AC Control Door, 58
Cable, Control Heater, 55
Ammeter Blank Scale Emergency Stop Switch, 74
Cable, Oil Heater, 42
Ammeter Blank Scale Oil Temperature Gauge, 73
Cable, Shielded Potentiometer Speed Adjusting, 71
Ammeter - Blank Scale Tachometer, 72
Cap, End Subbase Fuel Tank Dual Wall 12 or 24 Hour,
13
Band, Mounting Air Cleaner, 8
Cap, End Subbase Fuel Tank Single Wall 24 Hour, 11
Base, Auxiliary Terminal Block, 43
Cap, Fuel - Day Tank With Control, 17
Base, Relay Low Battery Voltage, 67
C;], Fuel Day Tank With Fuel Tank Pump and Control,
Basin, Rupture, 23
Bearing, Ball Generator, 49 C;~, Fuel Day Tank Without Fuel Tank Pump or Control,
Bell, End, 49
Block, Terminal Auxiliary, 43 Cap, Fuel Subbase Fuel Tank Dual Wall 12 or 24
Hour, 13
Block, Terminal Control Box, 57
Cap, Fuel Subbase Fuel Tank Single Wall 24 Hour, 11
Block, Terminal Generator Heater, 45
Cap, Radiator, 33
Board, Printed Circuit Alarm Relay, 61
Cap, Rain Muffler, 27
Board, Printed Circuit Common Alarm, 62
C::b~lnJ Subbase Fuel Tank Dual Wall -12 or 24
Board, Printed Circuit Electronic Overspeed, 63
Board, Printed Circuit Engine Monitor, 57 Capaciter, Voltmeter, 58
Board, Printed Circuit Fuel Tank Control, 22 Cartridge, Generator Heater, 45
Board, Printed Circuit Isolation Transformer, 60 Cleaner, Air, 8
Board, Printed Circuit Over/Under Voltage Relay, 64 Cock, Drain Radiator, 33
Board, Printed Circuit Time Delay Start/Stop, 65 Contact, Auxiliary Circuit Breaker Non-UL Approved, 77
Board, Printed Circuit Voltage Regulator, 60 Control, Electronic Governor, 25
Box, Control, 57 Control, Fuel Tank Components, 22
Box, Control - Fuel Tank, 22 Control, Fuel Tank Day Tank With Control, 17
Box, Entrance, 41 Control, Fuel Tank Day Tank - With Fuel Tank Pump and
Box, Mounting Circuit Breaker NonUL Approved, 77 Control, 19
Box, Mounting - Circuit Breaker UL Approved, 78 Control, Fuel Tank Subbase Fuel Tank Control, 21
Box, Mounting Control Housing, 40 Cover, Belt Guard - Remote Radiator, 31
Box, Terminal Generator Heater, 45 Cover, Box - Circuit Breaker - NonUL Approved, 77
Bracket, Mounting Air Cleaner, 8 Cover, Box Circuit Breaker UL Approved, 78
Bracket, Mounting Day Tank With Control, 17 Cover, Box Fuel Tank Control, 22
Bracket, Mounting Day Tank With Fuel Tank Pump and Cover, End Bell Overspeed Switch, 47
Control, 19 Cover, End Bell Permanent Magnet Exciter, 46
Bracket, Mounting Day Tank Without Fuel Tank Pump or Cover, Entrance Box, 41
Control, 15 Cover, Stator Generator, 49
Bracket, Mounting Electronic Governor Control, 25 Cover, Terminal Box Generator Heater, 45
Bracket, Mounting Float Switch, 24 Cushion, Vibration Engine End, 37
Bracket, Mounting Fuel Tank Pump Day Tank - With Cushion, Vibration - Generator End, 37
Fuel Tank Pump and Control, 19
Cutout, Cover - Circuit Breaker UL Approved, 78
Bracket, Mounting Fuel Tank Pump Subbase Fuel Tank
Control, 21
Dial, Wattmeter, 69
Bracket, Mounting Generator Foot, 49 Diode Low Coolant Level Sender With Continuously
Bracket, Mounting - Over/Under Frequency Relay, 66 Monitored Low Coolant Level 12 Light Indicator Controls,
Bracket, Mounting - Overspeed Switch, 47 29
Bracket, Mounting Remote Radiator, 31 Disc, Drive Generator, 49
B~3cket, Mounting Transformer Auxiliary Terminal Block, Door, Control AC, 58
Door, Control DC, 59
2
Index
Door, Housing, 35 Heater, Oil, 42
Hood, Air Inlet Air Cleaner, 8
Element, Air Cleaner, 8 Hose, Air Inlet, 8
Exciter, Permanent Magnet, 46 Hose, Fuel Day Tank - With Fuel Tank Pump and Control,
19
Fan, Alternator Engine, 39 Hose, Fuel Subbase Fuel Tank Control, 21
Fan, Radiator, 33 Hose, Oil Drain, 7
Fuse Engine Monitor Board, 57 Hose, Radiator, 33
Housing, Control, 40
Gasket, Float Valve Day Tank Without Fuel Tank Pump Housing, Generator Set, 35
or Control, 15
Hub, Drive Generator, 49
Gauge, Liquid Level Day Tank - With Control, 17
Gauge, Liquid Level Day Tank - With Fuel Tank Pump and Indicator, Service Air Cleaner, 8
Control, 19
Isolator, Vibration Control Box Mounting, 57
Gauge, Liquid Level Subbase Fuel Tank Dual Wall -12
or 24 Hour, 13
Kit, Heater Engine Coolant Heater, 30
Gauge, Liquid Level Subbase Fuel Tank Single Wall
24 Hour, 11 Kit, Repair Fuel Tank Pump Subbase Fuel Tank Control,
21
Gauge, Oil Pressure, 59
Gauge, Oil Temperature, 73 Lamp, Indicator Replacement - Fuel Tank Control, 22
Gauge, Water Temperature, 59 Latch, Housing Door, 35
Generator, 48,49,50 Lead Low Coolant Level Sender With Continuously
Governor, Electronic, 25 Monitored Low Coolant Level 12 Light Indicator Controls,
29
Grille, Housing, 35
Lead, Circuit Breaker NonUL Approved, 77
Grille, Radiator, 33
Lead, Circuit Breaker - UL Approved, 78
Guard, Belt Radiator, 33
Lens, Indicator Light - Basin Alarm Switch, 10
Guard, Belt Remote Radiator, 31
Lens, Indicator Light Low Battery Voltage, 67
Guard, Fan Generator, 49
Lens, Indicator Light Low Coolant Level Sender With
Guard, Fan Radiator, 33 Continuously Monitored Low Coolant Level 12 Light Indi
Guard, Radiator, 33 cater Controls, 29
Lens, Indicator Light Over/Under Voltage Relay, 64
Harness, Wiring AC Control Door, 57 Light Assembly, Indicator - DC Control Door, 59
Harness, Wiring Alarm Relay Board, 61 Light Assembly, Indicator Fuel Tank Control, 22
Harness, Wiring Auxiliary Terminal Block, 43 Light, Indicator Over/Under Frequency Relay, 66
Harness, Wiring Common Alarm, 62 Light, Indicator Upper/Lower Scale, 58
Harness, Wiring Current Transformer, 75 Light, Panel DC Control Door, 59
Harness, Wiring Day Tank With Control; 17 Line, Fuel Day Tank With Control, 17
Harness, Wiring Day Tank With Fuel Tank Pump and L~I, Fuel Day Tank With Fuel Tank Pump and Control,
Control, 19
Harness, Wiring DC Control Door, 57 Line, Fuel Day Tank Without Fuel Tank Pump or Control,
Harness, Wiring Electronic Overspeed, 63 15
Harness, Wiring Engine Coolant Heater, 30 Line, Fuel Fuel In Sets Without Subbase Fuel Tank, 7
Harness, Wiring Engine to Control, 57 Line, Fuel Fuel Out Sets Without Subbase Fuel Tank, 7
Harness, Wiring Fuel Tank Control, 22 Line, Fuel Subbase Fuel Tank - Dual Wall 12 or 24
Hour, 13
Harness, Wiring Low Battery Voltage, 67
Line, Fuel Subbase Fuel Tank Single Wall 24 Hour, 11
Harness, Wiring Low Coolant Level Sender With Contin
uously Monitored Low Coolant Level 12 Light Indicator Lug Set - Circuit Breaker NonUL Approved, 77
Controls, 29 Lug, Solderiess - Skid, 37
Harness, Wiring Low Coolant Level Sender Without
Continuously Monitored Low Coolant Level, 28 Meter, Frequency, 58
Harness, Wiring Over/Under Frequency Relay, 66 Meter, Time Totalizing, 59
Harness, Wiring Over/Under Voltage Relay, 64 Motor Fuel Tank Pump Day Tank With Fuel Tank
Pump and Control, 19
Harness, Wiring Permanent Magnet Exciter, 46
Motor Fuel Tank Pump Subbase Fuel Tank Control, 21
Harness, Wiring Subbase Fuel Tank Control, 21
Mount, Shock Over/Under Frequency Relay, 66
Harness, Wiring Time Delay Start/Stop, 65
Mount, Shock - Watts Transducer, 69
Harness, Wiring Wattmeter, 69
Muffler, 27
Heater Assembly, Control, 55
Heater, Engine Coolant, 30 Overspeed, Electronic, 63
Heater, Generator, 45
3
Package, Mounting Actuator to Injection Pump, 25 Standoff, Insulator Entrance Box, 41
Paint, 5 Starter, 38
Panel, Box - Circuit Breaker - Non-UL Approved, 77 Stator, Exciter, 49
Panel, Control Housing, 40 Stator, Generator - DGDA, 52
Panel, Side Housing, 35 Stator, Generator DGDB, 53
Pipe, Fuel Day Tank With Control, 17 Stator, Permanent Magnet Exciter, 46
P& Fuel Day Tank With Fuel Tank Pump and Control, Strap, Ground Control Box, 57
Strap, Ground Skid, 37
Pipe, Fuel Fuel Supply Day Tank Without Fuel Tank Support, Engine, 37
Pump or Control, 15
Support, Grille Radiator, 33
Plate, Mounting Audible Alarm, 68
Switch Blank Emergency Stop Switch, 74
Plate, Mounting - Electronic Overspeed, 63
Switch Blank Oil Temperature Gauge, 73
Plate, Mounting - Over/Under Frequency Relay, 66
Switch Blank Tachometer, 72
Plate, Mounting Voltage Regulator, 60
Switch, Basin Low Fuel Alarm, 9
Point, Overspeed, 47
S;~~,l~in Alarm Subbase Fuel Tank 12 and 24
Post, Housing, 35
Potentiometer Speed Adjusting, 71 Switc;, Float Basin, 24
Potentiometer Voltage Regulator, 60 Switch, Fuel Day Tank- With Control, 17
Pump, Fuel Tank Day Tank With Fuel Tank Pump and Stvvv~gFuel Day Tank With Fuel Tank Pump and Con
Control, 19
Pump, Fuel Tank - Subbase Fuel Tank Control, 21 Switch, Fuel Subbase Fuel Tank Control, 21
Switch, Oil Pressure, 7
Radiator, 33 Switch, Overspeed, 47
Rectifier Control Heater, 55 Switch, Pushbutton - Emergency Stop, 74
Regulator, Voltage Control, 60 Switch, Rocker DC Control Door, 59
Regulator, Voltage Engine Alternator, 39 Switch, Rocker Fuel Tank Control, 22
Relay - Alarm Relay Board, 61 Switch, Rotary Voltmeter/Ammeter, 58
Relay - Fuel Pump Fuel Tank Control, 22 Switch, Temperature High Engine Coolant, 7
Relay Over/Under Frequency, 66 Switch, Temperature - Low Engine Coolant, 7
Relay Over/Under Voltage, 64
Remote, Radiator, 31 Tachometer, 72
Resistor - Oil Temperature Gauge, 73 Tank, Day With Control, 17
Resistor Voltage Regulator, 60 Tank, Day With Fuel Tank Pump and Control, 19
Rotor - Permanent Magnet Exciter, 46 Tank, Day Without Fuel Tank Pump or Control, 15
Rotor, Exciter, 49 Tank, Fuel Subbase Single Wall 24 Hour, 11
Rotor, Generator, 49 TanolGrFr# Subbase Fuel Tank Dual Wall 12 or 24
Standoff, Insulator - Circuit Breaker Lead - Non-UL Ap Well, Thermostat Engine Coolant Heater,30
proved, 77 Wrapper,Fan Shroud- Radiator,33
Standoff, Insulator - Circuit Breaker Lead - UL Approved, W&~~;l Fuel Tank - Subbase Fuel Tank Single Wall -24
79
4
Abbreviations
Some of the following abbreviations maybe used throughout this Parts Catalog;
Alternating Current AC Not For Sale NFS
Ampere Amp Nominal Pipe Thread NPT
As Recmired A/R Outside Diameter OD
Automatic Voltage Regulator AVR Ounce oz.
American Wire Gauge AWG Permanent Magnet Exciter PMG
Degree Deg Phase Ph
Direct Current DC Printed Circuit Pc
External Tooth ET Radio Frequency Interference RFI
External/Internal Tooth EIT Right RT
Ground Fault Interrupter GFI Specification Spec
Inside Diameter ID Thick Thk
Internal Tooth IT Underwriters Laboratories Inc. UL
Kilowatt kW Union National Coarse UNC
Liquid Petroleum Gas LPG Union National Fine UNF
Left LT Volts Alternating Current VAC
Meter M(meter Number) Volts Direct Current VDC
Millimeter mm With W/( ET, IT, EIT)
5
External Engine Parts
100-2703
6
External Engine Parts
7
Air Cleaner
15
i
16
140-2155,6
18
REF
NO.
PART
NO.
QTY
USED
G /
PART
/6
DESCRIPTION
5
REF
NO.
PART
NO.
QTY
USED
PART
DESCRIPTION
8
Low Fuel Alarm
539-1287-02,04
9
Basin Alarm Switch
12 Hour and 24 Hour Subbase Fuel Tanks
539-1532
10
Subbase Fuel Tank
Single Wall
24 Hour
14
11
Subbase Fuel Tank
Dual Wall
12 or 24 Hour
18 1
16
20-
179-0696
Subbase Fuel Tank
Dual Wall
120r24Hour
13
Day Tank
Without Fuel Tank Pump or Control
4
\. %---6
20
[P)
6
Ocl
o
b
22
o
o
21
\
17
I
18
/
13 5
1 I \\\\
\\zi31
.....-.>.
,
)
8\
3
If
0
..,,
.. . ..+ . ..>.,
0
..,, Q
... ,:>
s .\\..~
w
..-.
k.,
~..,>,
,,.
+
..
539-1169-02
14
Day Tank
Without Fuel Tank Pump or Control
15
Day Tank
With Control
16
/
I \
17
12
539-1166-02
16
Day Tank
With Control
1 415-0575 1 Tank, Day (ll.8 Gallons) 13 415-0566-04 1 Pipe, Fuel (Fuel Supply)
2 415-0565-04 1 Gauge, Fuel (Liquid Level) 14 505-0049 1 Elbow, Pipe Street (1/8)
3 159-1206-01 1 Cap, Fuel 15 505-0018 1 Bushing, Reducer (1/2 to 1/4)
4 8215002-03 4 Screw, Self-Locking Hex 16 336-2398 1 Harness, Wiring Fuel Tank
Washerl-iead(l/4-20 xl/2) Control Box Printed Circuit
5 870-0550-05 2 Nut, Locking Flange Head Board TB1 to S1 + and Ground
(1/4-20) (2 Wire) (84)
6 308-0913 1 Switch, Fuel -5 Float 17 625-2141-01 1 Control, Fuel Tank (See
7 5010627-01 1 Line, Fuel - Flexible Tank to Separate Page For
Engine (With Filter) (21) Components)
8 5010502-02 1 Line, Fuel Flexible - Engine to 18 5020053 1 Elbow, Brass - Street - Low Oil
Tank (20) Pressure Switch (1/8)
9 503-0685 1 Clamp, Hose 19 505-0266 1 Plug, Pipe Square
10 505-0172 1 Nipple, Pipe Close (2) Countersunk (3/8)
11 1591206 1 Bracket, Mounting Fuel Tank 20 415-0752-01 1 Pipe, Fuel (Fuel Return)
12 8210018 6 Screw, SelfLocking Hex
Washer Head (1/4-20 x 5/8)
17
Day Tank
With Fuel Tank Pump and Control
23
19
.
22
8 \,
Ill l 3
9 !7%
Ft
\ z{/
10
/
/
25
/17 I \\d
,....,
;....
;Fw
r-l ,/i-:,
17
< f \
II/52?-J%%%,.1
w A i.--., ,
\
\
-.
7 \/
539-1043-02
18
Day Tank
With Fuel Tank Pump and Control
19
Subbase Fuel Tank Control
/)
10
1
I 7
2!
L
R
o 3
J 0
0 0
A , ....... 11
..,> .
L ..
....
....
...
/
13
-....
..,>
~.,..,.
.. 9
I
I
\ \
\ \
\
~
d
539-1533-03
20
Subbase Fuel Tank Control
21
Fuel Tank Control
A
3\t 2
,
6
7
17 625-2141
22
Rupture Basin
23
Float Switch
539-1288
24
Electronic Governor
,/
2 3 4
1
539-1439
25
Exhaust Adapter
e\/
!
2 I
179-1671
26
179-1672
27
.
Low Coolant Level Sender
Without Continuously Monitored Low Coolant Level
>.
: ...
179-2688-01,02
1 193-0322 1 Sender, Low Coolant Level (S7) 3 518-0548-15 1 Clip, Retaining Insulated
2 338-2871 1 Harness, Wiring - Shutdown
and Warning (3 Wire) (32)
28
.
Low Coolant Level Sender
With Continuously Monitored Low Coolant Level
12 Light Indicator Controls
,,.
,,-
300-4396
29
. .. . _________
Engine Coolant Heater
179-2237
30
Remote Radiator
F=+{
o
/
179-1292
31
Radiator
/\ 29
23
\ 28
k
16
6
111111111111111
28 / \l
15 .
A 26
,..-, -1,.>
[22:.:,,.
L
&T2.
14
7
/
.
179-1418
.__#y\,
32
Radiator
33
3
1
18
15
P
/
16
20
34
Housing
1 821-5004-02 20 Screw, SelfLocking Hex 12 405-5352 1 Post, Housing Rear - Left Side
Washer Head (3/8-1 6 x 3/4) 13 406-0807 2 Latch (Includes Key)
2 870-0281 22 Nut, Hex Locking (3/8-16) 14 406-0782 7 Key, Latch
3 405-5359 1 Top 15 816-0231-02 8 Rivet
4 405-3841 2 Door, Grille 16 506-0231 2 Bumper, Door
5 405-5364 2 Post, Housing Center 17 5170138-09 1 Plug, Hole (Fits 2-1/2 Hole)
6 815-0137 13 Screw, Hex Head Thread 18 5170135 2 Plug, Hole (Fits 5/8 Hole)
Forming (1/4-20 x 5/8) 19 406-0765-01 5 Latch (Includes Key)
7 405-5355 2 Door, Control Side 20 405-4932 6 Bumper, Door
8 405-5370 1 Door, Control Rear 21 405-3837 2 Panel, Housing Side
9 821500301 4 Screw, SelfLocking Hex 22 406-0574 4 Hinge, Door
Washer Head (5/16-18 x 1/2) 23 815-0236 4 Screw, Hex Head Thread
10 405-5351 1 Post, Housing Rear Right Forming (5/1 61 8 x 5/8)
Side 24 526-0115 4 Washer, Flat (5/1 6)
11 405-5386 1 Grille, Rear
35
20
18
/
36
Skid
37
_-
Starter
179-2629-05
38
.
Alternator
2
179-2644-02
39
Control Housing
Q
Q
4
K
\ /
300-3873
40
Entrance Box
%/- 5
.
3
/---0
319-2819
41
Oil Heater
1792283
42
Auxiliary Terminal Block
id P,
10
13
%- 12
5391075
43
..---
Generator Heater
-
? 3
14
18
16
I @ \ .
/
I
11
~..,
.
13
+
12
44
Generator Heater
45
Permanent Magnet Exciter
200-1286
1 3
46
Overspeed Switch
10
11
\4
3
\\
9 539-1052
2
47
.
14
46
50
200-3025
48
Generator
49
..-
14
46
50
38
31
200-3025
50
Generator
51
Generator Stator
DGDA
1 Stator, Generator
4 Lead, Single Phase, NonReconnectable
220-444&Ol 1 165mm Stack Length, 125 Deg C, 50 Hertz
220-4448-07 1 165mm Stack Length, 125 Deg C, 60 Hertz
220-4448-02 1 190mm Stack Length, 105 Deg C, 50 Hertz
220-4448-08 1 190mm Stack Length, 105 Deg C, 60 Hertz
220-4448-03 1 230mm Stack Length, 80 Deg C, 50 Hertz
220-4448-09 1 230mm Stack Length, 80 Deg C, 60 Hertz
6 Lead, Three Phase, Reconnectable
220-4448-31 1 165mm Stack Length, 105 Deg C
220-4448-31 1 165mm Stack Length, 125 Deg C
220-4448-32 1 190mm Stack Length, 80 Deg C
12 Lead
Three Phase, NonReconnectable
220-444&25 165mm Stack Length, 105 Deg C
220-444%25 165mm Stack Length, 125 Deg C
220-444&26 190mm Stack Length, 80 Deg C
Single or Three Phase, Reconnectable
220-444&13 1 165mm Stack Length, 105 Deg C, 50 Hertz
220-4448-13 1 165mm Stack Length, 105 Deg C, 60 Hertz
220-444S13 1 165mm Stack Length, 105 Deg C, 60 Hertz, Broad Range
220-444%1 3 1 165mm Stack Length, 125 Deg C, 50 Hertz, Broad Range
220-444G19 1 165mm Stack Length, 105 Deg C, 60 Hertz, Low Range
220-444&19 1 165mm Stack Length, 125 Deg C, 60 Hertz, Low Range
220-444&14 1 190mm Stack Length, 80 Deg C
220-4448-14 1 190mm Stack Length, 80 Deg C, 50 Hertz, Broad Range
220-4448-14 1 190mm Stack Length, 125 Deg C, Full Output on Single Phase
220-444%20 1 190mm Stack Length, 80 Deg C, 60 Hertz, Low Range
220-444%15 1 230mm Stack Length, 80 Deg C, 50 Hertz, Full Output on Single
Phase
220-4448-15 1 230mm Stack Length, 105 Deg C, 50 Hertz, Full Output on
Single Phase
220-4448-15 1 230mm Stack Length, 105 Deg C, 60 Hertz, Full Output on
Single Phase
220-4448-15 1 230mm Stack Length, 125 Deg C, 60 Hertz, Full Output on
Single Phase
220-444&l 6 1 285mm Stack Length, 80 Deg C, Full Output on Single Phase
52
Generator Stator
DGDB
1 Stator, Generator
4 Lead, Single Phase, NonReconnectable
220-4448-09 1 230mm Stack Length, 105 Deg C, 60 Hertz
220-4448-03 1 230mm Stack Length, 125 Deg C, 50 Hertz
220-4448-09 1 230mm Stack Length, 125 Deg C, 60 Hertz
220-4448-10 1 285mm Stack Length, 80 Deg C, 60 Herttz
220-4448-04 1 285mm Stack Length, 105 Deg C, 50 Hertz
220-444&05 1 335mm Stack Length, 80 Deg C, 50 Hertz
6 Lead, Three Phase, Reconnectable
220-4448-31 1 165mm Stack Length, 125 Deg C
220-4448-32 1 190mm Stack Length, 105 Deg C
220-4448-33 1 230mm Stack Length, 80 Deg C
12 Lead
Three Phase, Non-Reconnectable
2204448-26 1 190mm Stack Length, 105 Deg C
220-4448-26 1 190mm Stack Length, 125 Deg C
220-444&28 1 285mm Stack Length, 80 Deg C
Single or Three Phase, Reconnectable
22&444&l 9 1 165mm Stack Length, 125 Deg C, 60 Hertz, Low Range
220-4448-14 1 190mm Stack Length, 105 Deg C, 60 Hertz, Broad Range
220-4448-20 1 190mm Stack Length, 105 Deg C, 60 Hertz, Low Range
220-4448-14 1 190mm Stack Length, 125 Deg C, 50 Hertz, Broad Range
220-4448-14 1 190mm Stack Length, 125 Deg C, 60 Hertz, Broad Range
220-4448-21 1 230mm Stack Length, 80 Deg C, 60 Hertz, Low Range
220-4448-15 1 230mm Stack Length, 105 Deg C
220-4448-15 1 230mm Stack Length, 125 Deg C, Full Output on Single Phase
220-444&l 6 1 285mm Stack Length, 80 Deg C
220-4448-16 1 285mm Stack Length, 80 Deg C, 50 Hertz, Broad Range
220-4448-16 1 285mm Stack Length, 105 Deg C, 50 Hertz, Full Output on
Single Phase
220-444&l 6 1 285mm Stack Length, 105 Deg C, 60 Hertz, Full Output on
Single Phase
220-4446-16 1 285mm Stack Length, 125 Deg C, Full Output on Single Phase
220-444&l 7 1 335mm Stack Length, 80 Deg C, Full Output on Single Phase
220-444&l 8 1 375mm Stack Length, 80 Deg C, Full Output on Single Phase
53
54
..
Control Heater
300-4426
55
Control
/45 fl /-w
40
<
36
37 35
///
w .
\
25
30/
\ IIII!4
612-6487
56
Control
57
AC Control Door Assembly
11
2 9\ \
\
6
0
0
0
10-
Q
1 o
(2
o
7
612-6489
58
DC Control Door Assembly
3 11
13
1
15
59
Voltage Regulator
300-3606/7
60
Alarm Relay Board
4
/
61
Common Alarm
:...,
@@-
\
3
300-4394-02
62
Electronic Overspeed
I 2
q\
1
5 300-3601
63
Over/Under Voltage Relay
300-4697-01
64
Time Delay StartfStop
65
Over/Under Frequency Relay
1 -tin
1-6 11
w+ .
<) 5
+
t%,,.
6
7
30C-3141
66
Low Battery Voltage
300-4395
1 322046308 1 Lens, Indicator Light (Marked 5 870-1221 2 Nut, Hex - W/ET (#8-32)
Lo Battery) 6 305-0901 1 *Sensor Low Battery
2 338-3034 1 *Harness, Wiring (4 Wire) (36) Voltage (Kl 5)
(K15to All)
3 323-141 003 1 Base, Relay
4 81 20084 2 *Screw, Machine - Round Head * - Not Used on All Models
(#8-32 X 1)
67
Audible Alarm
,A.
P .
\
?5
.
d 2
/ /
,\,-.,..><,
/ ,/ ;;
/-s7-)
( \
, /%
300-3729
68
Wattmeter
8 4
9 ,,,....
,,, . , ;?,<
,., ,..
/ ,..
,.,
,.- ,./
,,,:. ;
,., ,,, : !
,,,,.
.,..
; .,.,..
8 ;,.~:
,...,,~:
,, . ,/.....1,,~,,
. ,/ ; .,,..
,,.;~
,,.
.:, ,.,,.:,
.;
,,.,.,
//
,.\=::,
/
,...-.,
,/ ! :
,! j ,,
,.
, ;
; <./;, ; ,, /,
-., ~ ~
.,, +?:<.
,
,,
i @
,1/1//
,,,.,,
i : ,,. ,,, .
......
/
1
n /
4
300-4736
69
Circuit Breaker
AC Control Door
,,,..-.. ~,
...,/.
,/ .;..
300-3765-01
..-
70
Potentiometer
Speed Adjust
71
Tachometer
---\
300-3350
72
Oil Temperature Gauge
,..
,,.
,,,, ;:,
..,,;
7
\ 6
73
Emergency Stop Switch
,,/,..
,.,, :
,,..,,.,
,...,,/.,,.-
,,,
/.;;::
,.,..;:
,.,
..
\
300-3127
74
Current Transformer
/
1 30(3-3338
75
-.
Circuit Breaker
Non-UL Approved
2
7
1
14
11 /
\
l 5\
16
B
13 o
0
00
%
12
63 0
5
o
b
0
0
7 0
/
o\8
\ \
\
\
.
J \ .\
I
Q
2
8
/-
6 .
3
76
Circuit Breaker
Non-UL Approved
77
Circuit Breaker
UL Approved
\
1P 5
l
o
0 0
625-3022
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
78
Circuit Breaker
UL Approved
REF PART QTY PART REF PART QTY PART
NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
1
* 450 Amp
10 Screw, Machine Round Head 320-1 4601 O
320-1460-11 1
*
81 20093 4 #8-32 X 3 500 Amp
*
813-0190 4 #1 o-32x 4 320-1 46012 1 600 Amp
812-0157 4 1/4-20 X 1-3/4 With Auxiliary Contacts
11 526-0008 4 Washer, Flat (#1 O) 320-1462-44 1 90 Amp
12 Washer, Lock 320-1462-45 1 100 Amp
850-0025 4 #8 Spring 125 Amp
850-0030 4 #1 O Spring 320-1 46230 1 480 Volt
854-0014 4 1/4 W/lT 320-1462-47 1 600 Volt
13 821500203 20 Screw, SelfLocking - Hex 150 Amp
Washer Head (1/4-20 x 1/2) 320-1462-31 1 480 Volt
14 506-0239 - Edging Bulk (Order By The 320-1462-48 1 600 Volt
Foot 2 Feet Required) 320-1463-08 1 175 Amp
15 332-2744-07 1 Standoff, Insulator 32&1463-09 1 200 Amp
16 800-0047 1 Screw, Cap Hex Head 320-1463-10 1 225 Amp
(3/6-1 6 X 5/8) 250 Amp
17 850-0050 1 Washer, Lock - Spring (3/8) 320-1556-15 1 240 Volt
18 091-0002 1 Strip, Copper (Used for 320-1464-06 1 600 Volt
wrapping ends of leads before 300 Amp
securing to circuit breakers) 320-1556-16 1 240 volt
(Quantity Used As Required) 320-1 46407 1 600 Volt
19 Breaker, Circuit (Includes Lugs) 350 Amp
(CB21) 320-1556-17 1 240 Volt
Two Pole Breakers 320-1 46408 1 600 Volt
Standard 320-1556-18 1 400 Amp
320-1 4641 O 1
* 450 Amp
320-1 55514 1 400 Amp
* 1
* 500 Amp
320-1 51310 1 450 Amp 32&146411
* 320-1 46412 1
* 600 Amp
32&l 51 311 1 500 Amp
* With Shunt Trip
32&l 51312 1 600 Amp
With Auxiliary Contacts 320-147045 1 100 Amp
320-1 5561 4 1 400 Amp 320-1470-30 1 125 Amp
* 320-1470-31 1 150 Amp
320-1516-10 1 450 Amp
* 320-1 47108 1 175 Amp
320-1516-11 1 500 Amp
* 32&147109 1 200 Amp
32&l 51612 1 600 Amp
* With Auxiliary Contacts and 320-1471-10 1 225 Amp
320-1 5371 2 1
Shunt Trip -600 Amp 320-1472-06 1 250 Amp
Three Pole Breakers 320-1472-07 1 300 Amp
Standard 350 Amp
320-1456-44 1 90 Amp 320-1 55765 1 240 Volt
320-1456-45 1 100 Amp 320-1472-08 1 600 Volt
125 Amp 320-1 55766 1 400 Amp
320-1 4721 O 1
* 450 Amp
320-1458-30 1 480 Volt
320-1472-11 1
* 500 Amp
320-1458-47 1 600 Volt
1
* 600 Amp
150 Amp 320-1 47212
320-1456-31 1 480 Volt With Auxiliary Contacts and
320-1456-48 1 600 Volt Shunt Trip
320-1459-08 175 Amp 320-1490-30 125 Amp
320-1459-09 200 Amp 320-149&31 150 Amp
320-1 4591 O 225 Amp 320-1491-08 175 Amp
250 Amp 320-1 49109 200 Amp
320-1555-15 240 Volt 320-1 4911 O 225 Amp
320-1460-06 600 Volt 320-1 49206 250 Amp
300 Amp 320-1492-08 350 Amp
320-1492-10 1
* 450 Amp
320-1555-16 1 240 Volt
320-1 4921 2 1
* 600 Amp
320-1460-07 1 600 Volt
350 Amp
320-1555-17 1 240 Volt
32&1460-08 1 600 Volt * Circuit Breakers With Interchangeable Trip
320-1555-18 1 400 Amp
79
-..
Numerical Index
Part No. Page Part No. Page Part No. Paae Part No. Paae
80
Numerical Index
Part No. Paae Part No. Paae Part No. Page Part No. Paae
81
Numerical Index
Part No. Page Part No. Paae Part No. Paae Part No. Paae
82
Numerical Index
Part No. Paae Part No. Paae Part No. Paae Part No. Paae
83
.
Numerical Index
Part No, Paae Part No. Paae Part No. Paae Part No. Paae
84