Eligibility
See the qualifications and additional eligibility requirements for the specific rebates.
CONTACT INFORMATION:
All correspondence and applications for the program should be directed to:
GVEC: 1‐800‐223‐GVEC (4832) or Fax # (830) 857 – 1223
Mail To: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
E‐Mail: info@gvec.org
Page 1
Cooling/Heating Systems:
Rebates For:
15 SEER ‐ $500.00/UNIT
16 SEER ‐ $600.00/UNIT
17 SEER ‐ $700.00/UNIT
QUALIFICATIONS:
• ALL UNITS SHALL BE AN ALL ELECTRIC HEAT PUMP SYSTEM
• Programmable thermostat shall be installed if not already existing.
• Auxiliary heating shall be controlled thru outdoor temperature sensor and set at the systems
balance point preventing unnecessary operation of auxiliary heating.
• Air distribution system (supply, return, plenum, and cabinet closet) shall be sealed or repaired
according to manufacturer’s recommended installation practices and current code
requirements.
• Unit shall be a NEW matching system certified by AHRI. Both condensing unit and air
handler/evaporator coil shall be replaced.
• APPLICABLE TO EQUIPMENT INSTALLED IN NEW OR EXISTING HOMES OWNED BY GVEC
MEMBERS AND LOCATED WITHIN THE GVEC SERVICE AREA.
• Manual J cooling load calculation to be completed showing the sensible load based on San
Antonio design conditions. Equipment sensible not to exceed 15% of the calculated sensible
load.
• Shall be installed by a contractor with a current “TACL” license.
• Manufactures installation practices and procedures shall be followed
• State and local codes shall be followed.
• Rebate excludes window units. SEE APPLIANCE REBATE PROGRAM FOR WINDOW UNITS.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• GVEC reserves the right to make changes to the program without notice.
• Equipment is eligible if installation is completed by a GVEC listed contractor. Please check out
our website at www.gvec.org for a complete list of rebates and contractors.
• In no way does GVEC assume responsibility for the work completed by a GVEC listed contractor.
• Applications shall be received 30 days after completion of project. Project shall be completed
after January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor (including above criteria) with your application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION:
All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC (4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 2
Attic Insulation
Rebates Of:
$0.20/sq. ft. of installed insulation
QUALIFICATIONS:
• Final insulation level minimum shall be R‐38 to qualify.
• (PRIOR TO UPGRADE) INSULATION SHALL BE R‐19 OR LESS.
• Garages and other non‐conditioned areas DO NOT qualify.
• Invoice shall include: insulation manufacturer, type, footage of conditioned area, starting and
final R‐Value.
• APPLICABLE ONLY TO GVEC MEMBERS AND EXISTING HOMES WITHIN SERVICE AREA (NO
NEW CONSTRUCTION).
• All material shall be new.
• Manufacture’s installation practices and procedures shall be followed.
• State and local codes shall be followed.
GVEC recommends that the attic have 1 sq. ft. of net free area of inlet ventilation
and outlet ventilation for every 300 sq. ft. of attic area.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Improvements are only eligible if completed by a GVEC listed contractor. Please
check out our website at www.gvec.org for a complete list of rebates and contractors.
• In no way does GVEC assume responsibility for the work completed by a GVEC listed
contractor.
• Applications shall be received 30 days after completion of project. Project must be completed
after January 1, 2010 to be eligible for rebates.
• Attach a dated invoice from the contractor or retailer (including above criteria) along with your
application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 3
Wall Insulation
Rebates Of:
$0.20/sq. ft. of installed insulation
QUALIFICATIONS:
• Rebate is based on the sq. ft. of installed insulation. (Calculated by gross wall area less window
and door area, etc.)
• FINAL INSULATION SHALL BE AT LEAST R‐13.
• WALL CAVITY TO BE VOID OF ANY INSULATION PRIOR TO UPGRADE IN ORDER TO QUALIFY.
• Garages and other non‐conditioned areas do not qualify.
• Shall be installed between conditioned and unconditioned areas to qualify.
• Invoice shall include: insulation manufacturer, type, square feet, and added R‐Value.
• APPLICABLE ONLY TO GVEC MEMBERS AND EXISTING HOMES WITH IN SERVICE AREA (NO
NEW CONSTRUCTION).
• All material shall be new.
• Manufacture’s installation practices and procedures shall be followed.
• State and local codes shall be followed.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Improvements are only eligible if completed by a GVEC listed contractor. Please
check out our website at www.gvec.org for a complete list of rebates and contractors.
• In no way does GVEC assume responsibility for the work completed by a GVEC listed contractor.
• Applications shall be received 30 days after completion of project. Project must be completed
after January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor or retailer (including above criteria) along with your
application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 4
Energy Efficient Windows:
Rebates Of:
$1.00/sq. ft. of window opening
QUALIFICATIONS:
• Rebate only for replacement of existing windows.
• WINDOW RATING SHALL HAVE A MINIMUM U‐FACTOR OF < .50.
• Windows shall have a solar heat gain co‐efficient (SHGC) < .35.
• Windows in Garages and other non‐conditioned areas do not qualify.
• Invoice shall include: window manufacturer, model, size, U‐Factor and solar heat gain co‐
efficient (SHGC).
• APPLICABLE ONLY TO GVEC MEMBERS AND EXISTING HOMES WITHIN SERVICE AREA (NO
NEW CONSTRUCTION).
• All material shall be new.
• Manufacture’s installation practices and procedures shall be followed.
• State and local codes shall be followed.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Improvements are only eligible if completed by a GVEC listed contractor. Please
check out our website at www.gvec.org for a complete list of rebates and contractors.
• In no way does GVEC assume responsibility for the work completed by a GVEC listed contractor.
• Applications shall be received 30 days after completion of project. Project must be completed
after January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor or retailer (including above criteria) along with your
application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 5
Window Solar Screens or/& Film:
Rebates Of:
$0.50/sq. ft. of window
QUALIFICATIONS:
• Rebate will apply to solar screens OR films on windows.
• Screens or Films on windows in Garages and other non‐conditioned areas do not qualify.
• Screen or film shall cover entire glass surface area for each fenestration.
• Minimum of 70% reduction of solar heat gain for solar screens and minimum .40 solar heat gain
co‐efficient (SHGC) for films.
• Invoice shall include: manufacture’s data on reflectivity or heat gain co‐efficient, product
identifiers, and performance rating specifications.
• APPLICABLE ONLY TO GVEC MEMBERS AND EXISTING HOMES WITHIN SERVICE AREA (NO
NEW CONSTRUCTION).
• All material shall be new.
• Manufacture’s installation practices and procedures shall be followed.
• State and local codes shall be followed.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Improvements are only eligible if completed by a GVEC listed contractor. Please
check out our website at www.gvec.org for a complete list of rebates and contractors.
• In no way does GVEC assume responsibility for the work completed by a GVEC listed contractor.
• Applications shall be received 30 days after completion of project. Project must be completed
after January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor or retailer (including above criteria) along with your
application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 6
Duct System Replacement:
Rebates Of:
20% of the cost, up to $500.00
QUALIFICATIONS:
• Duct material shall be insulated with R‐8.
• ONLY DUCTS IN UNCONDITIONED SPACE WILL QUALIFY (Any discrepancies of unconditioned
or conditioned area to be determined by GVEC).
• Invoice shall include: R value of material used.
• Dampers shall be installed in order to control room by room airflow.
• Adjustable louvered ceiling grills should not be a substitution for dampers.
• Contractor must hold a current certification showing proof of training in Blower Door, Duct
Blaster or National Comfort Institute (NCI) HVAC air diagnostics and balancing testing. Duct air
flow leakage testing results must show total preliminary duct leakage in CFM, final duct leakage
in CFM and nominal system tonnage.
• Duct system shall be sealed and tested to have ≤ 7 % CFM of air leakage based on the nominal
systems tonnage of 400 CFM per ton.
• Duct system shall be sealed and designed according to manufacturer’s recommended
installation practices and procedures, current state and local code requirements and ACCA
Manual D.
• APPLICABLE ONLY TO GVEC MEMBERS AND EXISTING HOMES WITHIN SERVICE AREA (NO
NEW CONSTRUCTION).
• All material shall be new. Air sealants such as mastics and/or foil tape shall be UL 181 approved
and designed for air distribution systems.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Improvements are only eligible if completed by a GVEC listed contractor. Please
check out our website at www.gvec.org for a complete list of rebates and contractors.
• In no way does GVEC assume responsibility for the work completed by a GVEC listed contractor.
• Applications shall be received 30 days after completion of project. Project must be completed
after January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from contractor (including above criteria) along with your application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 7
Radiant Barrier:
Rebates Of:
$0.10/sq. ft.
QUALIFICATIONS:
• Rebate is based on the amount of treated attic area NOT to exceed the square footage of
conditioned area.
• Acceptable materials include radiant barrier paint applied coatings ONLY.
• Paintable coatings shall be designed for buildings as radiant barriers and installed on the
underside of roof decks.
• Products will require a minimum ASTM emittence rating of .30
• Attach an itemized and dated invoice from the contractor (include radiant barrier
manufacturer, type and conditioned square feet) along with your application form.
• APPLICABLE ONLY TO GVEC MEMBERS AND EXISTING HOMES WITHIN SERVICE AREA (NO
NEW CONSTRUCTION).
• Manufacture’s installation practices and procedures shall be followed.
• State and local codes shall be followed.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Improvements are only eligible if completed by a GVEC listed contractor. Please
check out our website at www.gvec.org for a complete list of rebates and contractors.
• In no way does GVEC assume responsibility for the work completed by a GVEC listed contractor.
• Applications shall be received 30 days after completion of project. Project must be completed
after January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor or retailer (including above criteria) along with your
application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 8
Energy Star® Appliances:
Rebates Of:
10% of cost of appliance, up to $100/appliance
QUALIFICATIONS:
• Rebate is based on the purchase price of appliance prior to sales tax.
• Rebates do not apply to installation costs or other fees.
• Rebate only applies to Energy Star® rated appliances.
• Rebate available for replacement appliances and new home construction.
• Qualifying appliances include: Window Units, Refrigerator, Freezer, Clothes Washer, and
Dishwasher.
• All appliances shall be new, purchased by a GVEC member and installed in the GVEC service
area.
• Manufacture’s installation practices and procedures shall be followed.
• State and local codes shall be followed.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Please check out our website at www.gvec.org for a complete list of rebates.
• Applications shall be received 30 days after completion of project. Invoice must be dated after
January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor or retailer (including energy star rating) along with
your application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines.
The member may lose the rebate if GVEC cannot verify the information provided on the
application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 9
Water Heaters:
Rebates Of:
$100.00/Electric Water Heaters Energy Factor (EF) .94
QUALIFICATIONS:
• Rebate is based on the Energy Factor (EF) of .94 or greater.
• Rebate available for replacement units and new home construction.
• All water heaters shall be new and installed in the GVEC service area.
• Invoice shall include: Model number, serial number and EF rating as listed in GAMA.
• All exposed pipes shall be insulated on unit.
• Manufacture’s installation procedures shall be followed.
• State and local codes shall be followed.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Please check out our website at www.gvec.org for a complete list of rebates.
• Applications shall be received 30 days after completion of project. Invoice must be dated after
January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor or retailer (including above criteria) along with your
application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 10
Heat Pump Water Heaters:
Rebates Of:
$300.00/Heat pump water heater
QUALIFICATIONS:
• Rebate available for replacement units and new home construction.
• Design and location are key to the performance of a heat pump water heating unit.
• Be sure to consult with a GVEC Member Services Advisor prior to installation.
• Heat pump water heater units are to be installed according to manufactures guidelines and
recommendations.
• All Heat pump water heaters shall be UL listed.
• All water heaters shall be new and installed in the GVEC service area.
• Invoice shall include: Co‐efficient of performance, model and serial number.
• All exposed pipes shall be insulated.
• State and local codes shall be followed.
ADDITIONAL ELIGIBILITY REQUIREMENTS:
• Funding for the program is limited.
• GVEC reserves the right to make changes to the program without notice.
• Please check out our website at www.gvec.org for a complete list of rebates.
• Applications shall be received 30 days after completion of project. Invoice must be dated after
January 1, 2010 to be eligible for Rebates.
• Attach a dated invoice from the contractor or retailer (including above criteria) along with your
application.
• Submission of applications does not guarantee a rebate.
• Please allow 6 weeks after receipt of all documents to receive rebate.
• GVEC reserves the right to verify all projects in order to meet minimum program guidelines. The
member may lose the rebate if GVEC cannot verify the information provided on the application form.
CONTACT INFORMATION: All correspondence and applications for the program direct to:
GVEC: 1‐800‐223‐GVEC(4832) Fax Number: (830) 857‐1223
Mail to: GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
Page 11
Heat Pump Rebate Application
USE FOR HEAT PUMP UNITS ONLY
A rebate is available to encourage GVEC members to install energy efficient heat pumps with a 15 SEER or greater.
Please direct any questions to 1‐800‐223‐GVEC or visit GVEC website at www.gvec.org for complete details.
• Application must be completed and submitted within 30 days of installation of the unit.
• Unit must be installed after January 1, 2010.
• Applications are subject to verification. If the verification cannot be completed, the rebate will not be paid.
• The unit must be placed in service in the GVEC service territory. Removed equipment cannot be reused in the GVEC service
territory.
• The rebate recipient must be a GVEC customer. Please allow 6 weeks after receipt of all documentation to receive rebate.
• Program may be discontinued by GVEC at any time.
• The Heat Pump rebate is based on the AHRI published efficiency ratio.
15.0 SEER 16.0 SEER 17.0 SEER OR GREATER
$500.00/UNIT
$600.00/UNIT $700.00/UNIT
‐‐‐‐‐‐‐‐‐‐Documents Needed for Processing‐‐‐‐‐‐‐‐‐‐
o Legible copy of receipt itemizing equipment installed, model numbers and serial numbers.
o AHRI reference number & Manual J Calculation showing sensible load based on San Antonio design conditions
o Completed and signed application (All fields must be filled out completely to prevent processing delay)
Fax to: (830) 857‐1223; or mail to:
GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
TO BE COMPLETED BY MEMBER
Member Name GVEC Account Number
Address of Installation City State TEXAS Zip
Mailing Address City State Zip
Phone Number How did you hear about this program? New Home Existing Home
( )
TO BE COMPLETED BY CONTRACTOR
HVAC Contractor Name GVEC Contractor #
Phone Number Fax Number
( )
( )
Contact Name Install Date
INFORMATION ON NEW SYSTEM
Brand Square Feet Conditioned Space AHRI Reference Number
Model Number‐Condenser Serial Number‐Condenser SEER Rating Size (tons)
Model Number‐Air Handler Serial Number‐Air Handler
Make & Model‐Coil (If Applicable) Serial Number‐Coil
Under penalty of perjury, I certify that the above information is true and correct and I understand that the information is
subject to inspection and verification by Guadalupe Valley Electric Coop.
Customer Signature: Date:
Contractor Signature: Date:
GVEC Use Only GVEC Use Only GVEC Use Only
Reviewed By: Rebate approved by: Rebate Paid:
Keep a copy for your records.
Improvement Rebate Application
This rebate is available to GVEC Members and applies to energy efficiency upgrades. Project must be completed after
January 1, 2010. When you use a GVEC listed contractor, you can qualify to receive rebates. Submission of application
does not guarantee a rebate. Please allow 6 weeks after receipt of all documents to receive rebate. Please direct any
questions to 1‐800‐223‐GVEC or visit GVEC website at www.gvec.org for complete details.
• Application must be completed and submitted within 30 days of installation.
• Applications are subject to verification. If the verification cannot be completed, the rebate will not be paid.
• The rebate recipient must be a GVEC member.
• Program may be discontinued by GVEC at any time.
• Rebates are based on criteria listed below.
¾ Attic Insulation ‐ $0.20/sq. ft. of installed insulation
¾ Wall Insulation ‐ $0.20/sq. ft. of installed insulation
¾ Energy Efficient Windows ‐ $1.00/sq. ft. of window opening
¾ Window Solar Screens or Film ‐ $0.50/sq. ft. of window
¾ Duct System Replacement – 20% of the cost, up to $500.00
¾ Radiant Barrier ‐ $0.10/sq. ft. of installed material
MEMBERS, please complete the application and include both A, B, and C below. (All fields must be filled out completely to prevent processing delay)
‐‐‐‐‐‐‐‐‐‐Documents Needed For Processing‐‐‐‐‐‐‐‐‐‐
A. Signed application.
B. Work Sheet with appropriate information – include type, brand, sq. footage, manufacturer, etc.
C. Invoice showing work completed.
Fax to: (830) 857‐1223; or mail to:
GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
TO BE COMPLETED BY MEMBER
Member Name GVEC Account Number
Address of Installation City State TEXAS Zip
Mailing Address City State TEXAS Zip
Phone Number How did you hear about this program?
( )
Type of Rebates (Check all that apply.)
Attic Insulation Wall Insulation Energy Efficient Windows Solar Screens Window Film Duct Replacement Radiant Barrier
TO BE COMPLETED BY CONTRACTOR
Contractor Name GVEC Contractor #
Mailing Address City, State, Zip Code
Phone Number Fax Number
( )
( )
Contact Name Install Date
Under penalty of perjury, I certify that the above information is true and correct and I understand that the information is
subject to inspection and verification by Guadalupe Valley Electric Coop.
Customer Signature: Date:
Contractor Signature: Date:
GVEC Use Only GVEC Use Only GVEC Use Only
Reviewed By: Rebate approved by: Rebate Paid:
Keep a copy for your records.
Improvement Rebate Worksheet
This worksheet is to be filled out by Contractor and attached to the Application with the Invoice. GVEC reserves
the right to verify all projects in order to meet minimum program guidelines.
Member Name
Address of Installation City, State Zip Phone Number
( )
Type of Rebates ‐ (Check all that apply.)
Attic Insulation Wall Insulation Energy Efficient Windows Solar Screens Window Film Duct Replacement Radiant Barrier
Attic Insulation Type Square Feet Installed (Do Not Include Non‐ Pre‐Existing R‐Value Final R‐Value
t
Conditioned Area.)
Wall Insulation Type
Square Feet Installed (Do Not Include Non‐ Pre‐Existing R‐Value Final R‐Value
Conditioned Area.)
Energy Star Window Manufacturer and Model # of Windows Total Sq. Ft. of Windows SHGC U‐Factor
Solar Screens or Film Type & Manufacturer # of Windows Total Sq. Ft. of Windows SHGC/Films Heat Reduction
%/Screens
Duct Replacement Type R‐Value
Minimum R‐8
Radiant Barrier Type & Manufacturer ASTM Rating Sq. Ft. of Conditioned Space
t
Under penalty of perjury, I certify that the above information is true and correct and I understand that the information is
subject to inspection and verification by Guadalupe Valley Electric Coop.
Customer Signature: Date:
Contractor Signature: Date:
GVEC Use Only GVEC Use Only GVEC Use Only
Reviewed By: Rebate approved by: Rebate Paid:
Keep a copy for your records.
Energy Star® Appliance &
Water Heater Rebate Application
This application is to be filled out by Member and attached with the Invoice. Application shall be completed and
submitted within 30 days of purchase.
• Rebate only applies to Energy Star® rated appliances purchased after January 1, 2010.
• Applications are subject to verification. If the verification cannot be completed, the rebate will not be paid.
• The rebate recipient must be a GVEC member and installed in GVEC service area.
• Program may be discontinued by GVEC at any time.
• Rebates are based on criteria listed below.
¾ Window Units ‐ 10% of cost, up to $100.00
¾ Refrigerators ‐ 10% of cost, up to $100.00 Rebate is based on the
¾ Freezers ‐ 10% of cost, up to $100.00 purchase price of appliance
¾ Clothes Washer ‐ 10% of cost, up to $100.00 prior to sales tax.
¾ Dishwasher ‐ 10% of cost, up to $100.00
¾ Electric Water Heaters EF .94 ‐ $100.00
¾ Heat Pump Water Heaters‐$300.00
MEMBERS, please complete the application and include both A and B below.
‐‐‐‐‐‐‐‐‐‐Documents Needed for Processing‐‐‐‐‐‐‐‐‐‐
A. Signed application.
B. Detailed invoice showing Energy Star® make, model and cost of equipment.
Fax to: (830) 857‐1223 ; or mail to:
GVEC Rebate Program
P.O. Box 118
Gonzales, TX 78629
TO BE COMPLETED BY MEMBER
Member Name GVEC Account Number
Address of Installation City State TEXAS Zip
Mailing Address City State TEXAS Zip
Phone Number How did you hear about this program?
( )
Type of Rebates (Check all that apply.)
Window Unit Refrigerator Freezer Clothes Washer Dishwasher Electric Water Heater Heat Pump Water Heater
Energy Star® Model # & Manufacturer Energy Factor (EF) .94 or higher (Water Heaters ONLY)
Serial Number Coefficient of Performance (C.O.P.) (Heat Pump Water Heaters)
Under penalty of perjury, I certify that the above information is true and correct and I understand that the information is
subject to inspection and verification by Guadalupe Valley Electric Coop.
Customer Signature: Date:
GVEC Use Only GVEC Use Only
Reviewed By: Rebate approved by:
Keep a copy for your records.