Remove contaminants around Remove the protector. Select the dispensing period by pressing Once the dispensing period is set, screw When the selected dispensing period of
Battery PCB the MODE button. the mode cap back on. the Pulsarlube V has completed, remove
the lube point.
the lubricator from the application. If the product is installed at a 45
Screw Cap
or 90 angle, please use an angle
LCD Display This product is a adapter with a diameter greater than
2 4 8 11 disposible unit. Dispose
of remaining plastic
or equal to 1/4".
components complying
with local regulations for
recycling.
Warning
Piston Do not cut, puncture, or reuse
lubricator. Do not change or
Each single press of the button recharge the battery.
advances to the next setting as follows.
Ensure a clear passage using a manual Turn the mode cap counterclockwise Log the installation date and the scheduled
grease gun. Note1 Remove any hardened grease and unscrew the cap. date of lube cycle completion on the label
Lubricant by purging the lube point with a manual grease gun. Purge Mode of the Pulsarlube V.
Note2 The grease in the equipment and the grease
Reservoir For remote installation using an 8mm
contained in the unit should be the same or compatible.
PL6 Multi Purpose with MoS 2 Multipurpose lubricant fortified with extreme
pressure additives and MoS 2
PL7 Low Temperature Synthetic lubricant for extreme low temp
applications (below 15C)
PL10 Electric Motor Bearing High vibration-resistance lubricant