3 Microwave Circuits
Assignment #1
Assigned: 30 October 2016
Due: 12 October 2016
2. Using the parameter definitions, derive the [ABCD] parameters for a section of
lossless transmission line (parameters Zo, l, ). Convert these to the [S]
parameters using the parameters conversion formulas.
3. Using the combined SC, design a 2 element lossless lumped L circuit to match
zL = 1.8 + j0.3 to zo = 1. Repeat but instead tune an impedance of zo = 1 to
zL = 1.8 + j0.3 (ie: go the other way, as discussed in class). Do you get the
same solution as above?
for part (b), the balanced form of shunt stubs is shown below. For circuit (a),
assume the balanced stub Zos are the same as the single stub; for circuit (b),
assume the balanced stub lengths are the same as the single stub.