USER MANUAL
CONTENTS 2
10
11
16
17
DEVICE GUIDE 3
VAPOR PATH
LE D BEHAVIOR 4
CHARGING
Plug the cable into any standard USB adaptor and connect to
the Firefly2 charging dock.
Place Firefly2 on the charging dock: the LED light blinks blue
when charging and turns solid blue when fully charged.
The LED will blink green for three seconds and turn
solid green when its ready. Watch for the glow!
PLEASE NOTE: The Firefly will turn off after 30 seconds of holding the sensors, and the heating coil will not glow as bright towards the end of a vape session.
USING CONCENTRATES 7
PACKING CONCENTRATES
VAPING CONCENTRATES
The LED will blink green for a few seconds and turn
solid green when its ready.
BATTERY LEVELS
To check battery level, tap the right OP EN C LOSE
touch sensor three times quickly and
watch the LED indicator.
SETTINGS PAGE
Set heating prole
Connect Device
INFORMATION PAGE
Register your Firey 2 for immediate rmware updates,
faster support, and insider information.
HEATING PROFILES
Choose from 6 pre-set temperatures
CONCENTRATES 500F
IMPORTANT: Concentrates setting will cause
combustion if used with loose-leaf material!!!
HIGH 420F
MEDIUM 380F
LOW 340F
FIREFLY APP 14
FIRMWARE UPDATE
Download the latest version of the Firey app.
Firey2s LED will blink blue and then turn solid blue while
updating. The app screen will show progress of the update.
POWER TUNING
Give your vapor production a boost with the
Power Tuning feature.
Adjust the universal temperature output of your device,
one percent at a time!
Check your heat settings in the app and try a higher setting
(but do not use concentrates setting for loose-leaf to avoid
combustion)
Clear the vapor path and reseat the lid; make sure it is on snugly.
BATTERY LIFE
Keep Firefly2 on charging dock to ensure a charged battery.
Only activate touch sensors while you are vaping and remind
your friends of this when they vape with Firefly2 for their
first time.
CONCENTRATES
DO NOT overfill pad. If you already overfilled and the concentrate
dripped inside the heating element, use touch sensors to heat
and blow air OUT to remove matter from inside.
Use only Firefly cleaning implements. Never place the Firefly the following measures:
chassis in liquid. Clean the Firefly only when it is cool.
Reorient or relocate the receiving antenna.
! Please remove batter before cleaning your device.
Increase the separation between the equipment and receiver.
Environmental Conditions:
Connect the equipment into an outlet on a circuit different from
Ambient Temperature: 50 - 105F (10 ~ 40C) that to which the receiver is connected.
Ambient Humidity: 65+/-20%RH
Consult the dealer or an experienced radio/TV technician for
FCC code; 2AGT3 help.
This device complies with part 15 of the FCC Rules. Operation IC Caution:
is subject to the following two conditions: (1) This device may
not cause harmful interference, and (2) this device must accept This device complies with Industry Canadas license-exempt RSSs.
any interference received, including interference that may cause Operation is subject to the following two conditions:
undesired operation. (1) This device may not cause interference; and
Any Changes or modifications not expressly approved by the (2) This device must accept any interference, including
party responsible for compliance could void the users authority interference that may cause undesired operation of the device.
to operate the equipment.
Hereby, NWT Holdings Inc, declares that Firefly 2, is in compliance
This equipment has been tested and found to comply with the with the essential requirements and other relevant provisions of
limits for a Class B digital device, pursuant to part 15 of the Directive 1999/5/EC.
FCC Rules. These limits are designed to provide reasonable
protection against harmful interference in a residential Environmentally friendly disposal:
installation. This equipment generates uses and can radiate radio
You can help protect the environment! Please
frequency energy and, if not installed and used in accordance
remember to respect the local regulations: hand
with the instructions, may cause harmful interference to radio
in the non-working electrical equipments to an
communications. However, there is no guarantee that interference
appropriate waste disposal centre.
will not occur in a particular installation. If this equipment does
cause harmful interference to radio or television reception, which
can be determined by turning the equipment off and on, the user
is encouraged to try to correct the interference by one or more of