Attach to Vol. No.

: TT187E-01, TT178E-01
CAUTION: Parts numbers on the drawing are provided only for reference purpose.
ZAXIS110/120/200/225USR/230/270/330 CONNECTORS To order parts on the drawing, be sure to consult the Parts Catalog.

THESE CONNECTORS ARE THE HARNESS END

CONNECTORS, UNLESS OTHERWISE SPECIFIED.

FUEL GAUGE BUZZAR CANCEL SW. AMBIENT SENSOR SOLAR-RADIATION SENSOR

(TRAVEL ALARM) (120 GROUP) (120 GROUP)

YAZAKI YAZAKI
YAZAKI 7323-2064

QOS CONTROLER COMPRESSOR PUMP/H(ENG SIDE) AMBIENT SENSOR SOLAR-RADIATION SENSOR AIR-CON PRESSURE SW.
(200 GROUP) (200 GROUP) (200 GROUP)

LOCK

2P FEMALE
YAZAKI 7123-7464-40 YAZAKI 7323-6214-40 SUMITOMO 6188-0494 SUMITOMO 6189-0533

DIODE SPEAKER PRESSURE SENSOR(L) GLOW RELAY OPTION POWER WWES

SWING ALARM

WATER PROOF PLUG CONNECTOR

MALE SHARE PLUG
YAZAKI 7113-1020
WATER PROOF CAP
YAZAKI 7120-8018
FEMALE RECEPTACLE
YAZAKI YAZAKI GROUND YAZAKI 7115-1050
YAZAKI 7283-1223-30 YAZAKI RV03FB YAZAKI 7323-2044 WATER PROOF CAP
YAZAKI 7120-1157
CONNECTOR
ALTERNATOR LEARNING SW. BOOM DUMPING FLAT TERMINAL
PRESSURE SENSOR(H) SOLENOID WIPER(CAB/H-SIDE) HYD. OIL TEMP. SENSOR WASHER
(ENG. OIL PRESS. SW.)
SCREW TERMINAL FLAT TERMINAL
LOCK WITH LOCK
AMP 172320-2

3P-FEMALE SUMITOMO 6189-0031 (CN. WITH OUT LOCK) YAZAKI 7323-1424-40

RELAY EO LEVEL RAD. LAVEL N-SENSOR EC ANGLE SENSOR EC-MOTOR STARTER SW. WIPER
COOLANT TENP. SW. BOOM DUMPING

SUMITOMO 6098-1493 YAZAKI 7323-7414-40 SUMITOMO 6189-0133 ALTERNATOR

COOLANT LEVEL SW
ML-CRANE WASHER
ENG. OIL PRESSURE SW.
RADIO GLOW RELAY
STARTER RELAY
BATTERY RELAY
DETAIL 1 AIR CLEANER RESTRICTION SW
BODY LIGHT
FUEL GAUGE

DIODE(1, 3)
YAZAKI 7123-1402
EARTH LINE WIPER
HORN SW
MCX-A MCX-B MCX-C MCX-D LEARNING SW

CAB
RADIO
S-REINFORCEMENT PLATE

AUX. POWER
BOOM DUMPING POWER LIGHTER

MONITOR
AIR-CON
TRAVEL ALARM
MONITOR A (CAB/H SIDE) MONITOR B (CAB/H SIDE) MONITOR C (CAB/H SIDE)
ADDITIONAL PUMP ATT1
ADDITIONAL PUMP ATT2 CONTROL SYSTEM
GROUND LINE
POWER DIGGING SW

MONITOR A MONITOR B MONITOR C SATELLITE/PC

DETAIL 2

CAB COVER

S-REINFORCEMENT PLATE

FLAME