ENGINEERING TUTORIAL
(HTTP://ENGINEERINGTUTORIAL.COM)
SHARE
Adsby Google
QuestionsAnswers InterviewAnswers ACPowerSystem
Earth wire is provided above the overhead transmission lines for protection against lightning strokes. The ground wire or earth wire protects the phase conductors
or line conductors by attracting itself the lightning strokes which in its absence would strike the phase conductors. Also the ground wire reduces the voltage
electrostatically or electromagnetically induced in the conductors by the discharge of a neighboring cloud. It also provides the additional protective effect by causing
the attenuation of traveling waves set in the lines by acting a short circuit secondary of the line current.
What is meant by protective angle? Give its value for reliable operation?
Protective angle is the vertical angle through the ground wire axis and the line passing from the ground wire axis to the outermost phase conductor. Its value for
reliable protection is taken equal to 20-30 degrees.
What is the difference between the lightning arrester and surge absorber?
Lightning arrester limits the duration and amplitude of the follow current while a surge absorber reduces the steepness of the wave front for a particular surge.
A Surge Diverter is a device that is connected between line and earth, i.e, in parallel with the equipment under protection at the substation. It limits the duration and
amplitude of the follow current.
Impulse ratio of any lightning arrester is the ratio of breakdown voltage of the wave of special duration to breakdown voltage of a 50Hz wave.
Voltage surge is sudden excessive rise in voltage that may be dangerous to the electrical equipment of an installation. Voltage surge cause damage to insulation of
the system. Voltage surges are caused because of lightning, switching on and off the load at high voltages.
http://engineeringtutorial.com/powersystemstabilityinterviewquestionsanswers/ 1/4
1/3/2017 HighVoltageandPowerSystemStabilityInterviewQuestionsEngineeringTutorial
In nite bus has constant voltage, constant electrical angle of the voltage, constant frequency, in nite fault level and therefore the quantities of the in nite bus do not
get affected by connecting or disconnecting of individual generator or transmission line.
Angle between rotor pole axis and stator rotating eld axis (which is rotating at synchronous speed) is called load angle. It is expressed in electrical degrees or
electrical radians.
Steady state stability of the system can be increased by either increasing the excitation of machine or group of machines, by reducing the transfer reactance.
Steady state stability refers to the conditions of the stability response to small and gradual changes of the load while transient stability corresponds to conditions of
the stability in response to large sudden disturbances. A sudden large disturbances includesoccurrenceof faults in the system and clearing of faults, sudden load
changes,in adventtripping of transmission lines or generators from the power system.
On what basis can we conclude that synchronous generator goes out of stability?
If the power angle exceeds the critical angle of the load, synchronous machine goes out of stability
Related Articles :
Generator Protection Interview Questions & Answers (http://engineeringtutorial.com/synchronous-generator-protection-interview-questions-answers/)
http://engineeringtutorial.com/powersystemstabilityinterviewquestionsanswers/ 2/4
1/3/2017 HighVoltageandPowerSystemStabilityInterviewQuestionsEngineeringTutorial
CompareaHugeParts FindPrice,Availability&Datasheets
Selection FromTheTopDistributors
Worldwide.
SearchFindchips&SaveToday
SHARE ON
(http://www.facebook.com/sharer.php?
(http://twitter.com/share?
(https://plus.google.com/share?
(http://www.tumblr.com/share/link?
(http://www.linkedin.com/shareArticle?
u=http%3A%2F%2Fengineeringtutorial.com%2Fpower-
url=http%3A%2F%2Fengineeringtutorial.com%2Fpower-
url=http%3A%2F%2Fengineeringtutorial.com%2Fpower-
url=http://http%3A%2F%2Fengineeringtutorial.com%2Fpower-
mini=true&url=http%3A%2F%2Fengineeringtutorial.com%2Fpower-
system- system- system- system- system-
stability- stability- stability- stability- stability-
interview- interview- interview- interview- interview-
questions-
questions-
questions- questions-
questions-
answers%2F)
answers%2F&text=High%20Voltage%20and%20Power%20System%20Stability%20Interview%20Questi
answers%2F) answers%2F&name=High%20Voltage%20and%20Power%20System%20Stabi
answers%2F)
(http://engineeringtutorial.com/voltage-control-circuit-beakers-interview-questions/)
PREVIOUS ARTICLE
http://engineeringtutorial.com/powersystemstabilityinterviewquestionsanswers/ 3/4
1/3/2017 HighVoltageandPowerSystemStabilityInterviewQuestionsEngineeringTutorial
(http://engineeringtutorial.com/transmission-lines-protection-questions-answers/)
NEXT ARTICLE
No comments
Message
Name*...
Email*...
Website...
SEND
CATEGORIES
Categories
Select Category
http://engineeringtutorial.com/powersystemstabilityinterviewquestionsanswers/ 4/4