Nominal
4.5 - 150 5 - 300*** 5 - 300*** 4 - 150*
thickness (t)(mm)
Tensile strength
340 - 510* 430 - 580* 490 - 640* 780 - 930*
(Mpa)
275 min*
Yield strength 300 min*
235 min* 350min* 700*
(Mpa) 275 min*
275 min*
Minimum
22* 20* 18* 14 - 18
Elongation
27 @ -50C
Impact strength(J) 27 @ +20C 27 @ +20C 27 @ 0C
(depending on grade )
As per mill
Bend radius 1 - 25 t ** 3 t min** 3 t min**
specification
Structural steel
Structural steel- Higher strength structural High strength allows for mass
general purpose
PAGE 01
Comments General purpose good impact values - even savings in design. Very good
Good formability
Good formability better when normalised. cold forming properties.
Readily available
EN 10028 P 265 series EN 10028 P 355 series Wearplate 200 Bennox
Material Grade EN 10028 P 295 series
ASME A 516 Gr. 60 ASME A 516 Gr. 70 SS10/200
Nominal
6 80 8 50 See data sheet 5 - 50
thickness (t)(mm)
650 780
Tensile strength
N/A N/A See data sheet Not measured or
(Mpa)
guaranteed
420 530
Yield strength
1000 1000 Not measured or
(Mpa) guaranteed*
14
Minimum
14 - 18 14 - 18 Not measured or
Elongation garuanteed
27 @ -40C
Impact strength(J) 20 @ -40C See data sheet
(depending on grade )
Mandatory
Mill certificate Mandatory Mandatory Mandatory
(Analysis only)
Comments
cold forming properties. Sheets Sheets 400bhn e.g. for improved results
(High Carbon Content)
Wear resistant plate Wear resistant plate Wear resistant plate Full range
Material Grade 400 BHN 450 BHN 500 BHN Chromium Carbide
Mill of origin - Europe Mill of origin - Europe Mill of origin - Europe overlay products
Nominal
6 - 130 6 - 100 6 80 6/6 - 19/10
thickness (t)(mm)
Tensile strength
1250 1400 N/A N/A
(Mpa)
Yield strength
1000 1200 N/A N/A
(Mpa)
Minimum
10 - 16 % 10 N/A
Elongation
N/A
Impact strength(J) 40 @ -40C 35 @ -40C 30 @ -40C
As per mill
As per mill specification As per mill
Weldability specification
( very good weldability ) specification
( very good weldability )
Comments good impact resistance, & combination with good cold where very high wear resistance
wear applications
good cold bending properties. forming properties. is required