0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
129 tayangan1 halaman
ANSYS uses consistent units across different systems of measurement. The consistent units used in ANSYS include kilograms, meters, seconds for mass, length, and time respectively. Other consistent units include kelvin for temperature, newtons for force, newtons per meter squared for pressure, and watts for conductivity, heat flux, and point heat generation. ANSYS does not require specification of units as it assumes all units used are part of a consistent set.
ANSYS uses consistent units across different systems of measurement. The consistent units used in ANSYS include kilograms, meters, seconds for mass, length, and time respectively. Other consistent units include kelvin for temperature, newtons for force, newtons per meter squared for pressure, and watts for conductivity, heat flux, and point heat generation. ANSYS does not require specification of units as it assumes all units used are part of a consistent set.
ANSYS uses consistent units across different systems of measurement. The consistent units used in ANSYS include kilograms, meters, seconds for mass, length, and time respectively. Other consistent units include kelvin for temperature, newtons for force, newtons per meter squared for pressure, and watts for conductivity, heat flux, and point heat generation. ANSYS does not require specification of units as it assumes all units used are part of a consistent set.
Consistent Units Q: What units does ANSYS use? A: ANSYS does not require a specification of the units to be used, as the assumption is that you are working in a consistent set of units. Consistent Units in each system are shown below:
SICGS BIN BFT NMM
Mass 1 1000 5.71e-3 0.0685 0.001 kg g lbs2/in slug tonne Length 1 100 39.37 3.281 1000 m cm in ft mm Time 1 1 1 1 1 s s s s s Temp 1 1 1.8 1.8 1 K K R R K Density 1 0.001 9.357e-8 0.00194 1e-12 3 kg/m g/cm3 lbs2/in4 slug/ft3 tonne/mm3 Force 1 100000 0.2248 0.2248 1 N dyne lb lb N Pressure 1 10 0.000145 0.0208 1e-6 2 N/m dyne/cm2 psi psf N/mm2 Conductivity 1 0.01 1.3375e-5 1.605e-4 0.001 W/mK W/cmK BTU/insR BTU/ftsR W/mmK Heat Flux 1 1e-4 6.11e-7 8.80434e-5 1e-6 2 W/m W/cm2 BTU/sin3 BTU/sft3 W/mm2 Film Coeff. 1 1e-4 3.39e-7 4.8913e-5 1e-6 2 W/m W/cm2 BTU/sRin2 BTU/sRft2 W/mm2 Point Hgen 1 1 9.478e-4 9.478e-4 1 W W BTU/s BTU/s W Acceleration 1 100 39.37 3.281 1000 2 m/s cm/s2 in/s2 ft/s2 mm/s2 Moment 1 1e7 8.85 0.73757 1000 Nm dynecm inlb ftlb Nmm Body Hgen 1 1e-6 1.55e-8 2.6834e-5 1e-9 3 W/m W/cm3 BTU/sin3 BTU/sft3 W/mm3
IDAC - Finite Element Analysis Software and CAE Consulting