0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
94 tayangan2 halaman
This document summarizes thermowell velocity calculations for a project. Key details include:
- The fluid is water operating at 100°F and 0 psi pressure with a velocity of 10 ft/s.
- Calculations show the wake frequency is below 40% of the natural frequency, meeting criteria.
- Steady state and dynamic stress are well below limits with safety factors over 29.
- Material is 316 stainless steel and all design parameters meet specified limits and codes.
This document summarizes thermowell velocity calculations for a project. Key details include:
- The fluid is water operating at 100°F and 0 psi pressure with a velocity of 10 ft/s.
- Calculations show the wake frequency is below 40% of the natural frequency, meeting criteria.
- Steady state and dynamic stress are well below limits with safety factors over 29.
- Material is 316 stainless steel and all design parameters meet specified limits and codes.
This document summarizes thermowell velocity calculations for a project. Key details include:
- The fluid is water operating at 100°F and 0 psi pressure with a velocity of 10 ft/s.
- Calculations show the wake frequency is below 40% of the natural frequency, meeting criteria.
- Steady state and dynamic stress are well below limits with safety factors over 29.
- Material is 316 stainless steel and all design parameters meet specified limits and codes.
Fluid W Water Natural Frequency (fn) 523 Hz Operating Temperature T 100 F Wake Frequency (fs) 42 Hz Operarating Pressure P 0 psi Frequency Ratio (fs/fn) 0.08 Fluid Velocity * V 10.0 ft/s Frequency Criteria fs < 0.4 fn Density r lb/ft Wake Frequency Limit 209 Hz PASS Viscosity (Dynamic) lb/ft-s x 10-6 (Dynamic = Kinematic x Density) * Velocity can be calc from Flow Rate & Pipe ID PRESSURE STRESS (See equation on S3) Pressure Limit 65 psi Max Operating Pressure 0 psi WELL DATA Safety Factor 433.3 PASS Mounting F Flanged (Flange incl in Pressure Calc) Yes Shank T Tapered Unsupported Length L 7.5 in STEADY-STATE STRESS Root Diameter A 1.063 in Stress Limit 23,550 psi Tip Diameter B 0.625 in Stress @ Design Velocity 166 psi Bore Diameter d 0.260 in Safety Factor 141.6 PASS Fillet Radius at Root b 0.000 in Min Tip Thickness t 0.188 in DYNAMIC STRESS Shielded Length Lo 14.0 in Stress Limit 7,655 psi N.R. Stress @ Design Velocity 264 psi N.R. Safety Factor 29.0 PASS Flange Rating (ref S3) Pf 67 psi Mtg Code (ref S2) FT FT Cyclic Stress @ In-Line Resonance Material 13 13 316 Fluid Velocity (for In-L Resonance) 49 fps Modulus of Elasticity E 23.8 psi x 10-6 In-Line Stress Calculation NOT Required Allowable Stress S 15.7 psi X 10-3 Stress @ In-L Resonance 639,885 psi Fatigue Stress Limit Sf 9.10 psi X 10-3 Safety Factor 0.0 N.R. Well Density Pm 0.285 lb/in