3. Operator shall mention in his __ manual as to when and where MEL item will be attended to
a) Quality control manual b) Aircraft maintenance manual
c) Maintenance system manual d) Quality assurance manual
4.If there is no defect reported by the crew in previous days flight : (series C-II)
a) AME will release the a/c for next day flight
b) AME will not release the a/c for next day flight
c) AME will consult the Q.C.M. and release the a/c for next day flight
d) AME will release the a/c if a NIL entry has been made in the P.D.R. by the pilot signed
5.The MEL item shall be repaired within three consecutive calendar days comes under
a) Cat D b) Cat B c) Cat C d) Cat A
6.Aircraft rules 7 B specifies that all Indian registered aircrafts shall carry on board
a) First Aid kit and Physicians kit
b) Cockpit check list & emergency check list
c) Up dated CAR
d) Flight manual
07.A list containing items of inspection/action to be performed by the flight crew, in the order as
listed, and in the circumstances as indicated, for ensuring safe operation of air craft is called
a) Cockpit check list b) Emergency check list
c) Flight inspection d) scheduleFlight manual
08. For Light Aeroplane piston engine Average fuel and oil consumption record should be
maintained by
a) Approved flight engineer
b) Approved flight engineer examiner
c) Aircraft maintenance engineer
d) An appropriately licensed maintenance engineer
9. The main purpose of investigation of defect:
a) is to avoid reoccurrence of defect
b) to find the person who has caused the defect
c) none
d) all are correct
10. Cockpit check list & emergency check list for each type of aircraft is prepared by:
a)Operator b)Manufacturer c)QCM d)None
11. The performance of task required to ensure the continuing airworthiness of an aircraft,
including any one or combination of overhaul, inspection, replacement, defect rectification and the
embodiment of a modification or repair or test.
a) Inspection b)Repair
c) Maintenance d)None
12.. The avg. fuel and oil consumption of piston engine is recorded in
a) Airframe engine log book b) Airframe Log book
c) Engine Log book d) Aircraft Technical Log
13.The state which the risk of harm to person or of property damage is reduced to a and maintained
at or below an acceptable level of safety through a continuing process of hazard identification and
risk management.
a)Flight safety b)Safety over sight function
c)Safety d) None
SUBJECTIVE
Ques 1. Write the definition
a) Aircraft
b) Aerodrome
Ques2. What are the occasion to carry out periodical recording of fuel and oil consumption of light
piston engine aircraft.