Metrology lab
To demonstrate the theoretical concepts taught in Mechanical Measurements &
Metrology.
To understand and use various measuring tools.
To understand calibration of various measuring devices.
Do not touch anything with which you are not completely familiar.
Carelessness may not only break the valuable equipment in the lab but may
also cause serious injury to you and others in the lab.
Please follow instructions precisely as instructed by your supervisor. Do not
start the experiment unless your setup is verified & approved by your
supervisor.
Do not leave the experiments unattended while in progress.
Do not crowd around the equipments & run inside the laboratory.
If any part of the equipment fails while being used, report it immediately to
your supervisor. Never try to fix the problem yourself because you could
further damage the equipment and harm yourself and others in the lab.
Keep the work area clear of all materials except those needed for your work
and cleanup after your work.
No. Name of Specifications
Equipment/Instrument
1 Outside micrometer 25 -50mm
Least Count 0.01mm
4 Digital Vernier Caliper 300 mm
Least Count 0.02mm
Resolution : 0.01mm/0.0005inch
5 Vernier Depth Gauge 300 mm