The circuit in Fig. 5 is a simple tone-ringing generator or ringing
oscillator that has many applications. For instance, it can be used as an alarm for electronic devices or toys and other input-voltage- level-sensing circuits. The 741 op-amp is wired as a band pass filter, but when a pulse of at least 5-volts peak shocks its input, the band pass filter becomes a ringing oscillator. Capacitors C2 and C3 and resistor R2 determine the fixed frequency and duration of the ringing signal. The 1500-ohm potentiometer, R3, can be used to vary the period of the ringing frequency. Transistors Q1 and Q2 are added to increase the power output of the op-amp to drive an 8-ohm speaker. With the values shown, the selectivity, or Q, of the filter is about 10 at a nominal frequency of 100 Hz. Nice simple design, Craig, I am sure hobbyists can find many uses for this type of circuit. +12V Fig. 5. This simple tone-ringing generator circuit can he used in many applications requiring a voltage level-sensing alarm indication. The 741 single op-amp can be replaced with an NTE 941M or a Thomson SK3514 op-amp.