(CAD)
11CD108 Plasticity and Metal Forming First Series Test
Time: 1.30hrs. Date: 22.08.2017 Max. Marks: 50 Marks
PART-A (9 x 2 = 18 marks)
Answer ALL Questions
PART-B (2 x 16 = 32 marks)
Answer ALL Questions
11. What do you understand by yield criteria? Explain the two yield criterias
commonly used? (CO1)
Or
12. Explain Mohrs circle representation of a state of stress in two and three
dimensional with simple sketches. (CO1)
13. The following data pairs (load kN; extension mm) were obtained from the plastic
part of a load-extension file for a tensile test on a extra deep drawing quality steel
sheet of 0.8 mm thickness. The initial test-piece width was 12.5mm and the gauge
length 50mm.
1.57,0.080;1.90,0.760;2.24,1.85;2.57,3.66;2.78,5.84;2.90,8.92;2.93,11.06;2.94,13.49;
2.92,16.59;2.86,19.48;2.61,21.82;2.18,22.69
Obtain engineering stress-strain, true stress, strain and log stress, log strain curves.
From these determine: initial yield stress, ultimate tensile strength, true strain at
maximum load, total elongation and the strength coefficient, and strain-hardening
index. (CO2)
Or
14. Determine the instability strain in terms of n for a thin-wall sphere subjected to an
internal pressure P and also find the Maximum pressure relation. Assume = Kn.
(CO2)