Anda di halaman 1dari 4

747- 400 CHECKLIST NORMAL PROCEDURES 1.

POWER-UP Standby Ignition Switch .................... NORM


Continuous Ignition Selector ................ OFF
Circuit Breakers .................................. CHECK Auto Ignition Selector...................... SINGLE
Battery Switch...........................................ON Autostart Switch....................................... ON
Standby Power Selector ....................AUTO L and R Jettison Nozzle Switches............ OFF
Fire Detection Panel .........................NORMAL Jettison Control Selector .......................... OFF
Fuel Control Switches.................... CUTOFF All Fuel Pumps ....................................... OFF
Start Knobs....................................... CLOSED Fuel X-Feed Switches .......... AS REQUIRED
Alternate Flaps ..............OFF and DISARMED Wing Anti-Ice ......................................... AUTO
Landing Gear Lever..............................DOWN Nacelle Anti-Ice ........................................ OFF
Flap Position Indicator & Lever .......... AGREE Windshield Wiper Switches...................... OFF
Weather Radar ......................................... OFF Windshield Heat Selectors ...................... ON
Electrical Power, EXT or APU ...ESTABLISH Passenger Oxygen Switch ................... NORM
Main and APU Battery Voltage........... CHECK Yaw Damper Switches ............................. ON
Exterior Lights ...................... AS REQUIRED Landing Altitude..................................... AUTO
Interior Lights.......................... AS REQUIRED Outflow Valve Manual Switches............... OFF
Ground Interphone ................................... SET Outflow Valves ........................ VERIFY OPEN
Cabin Altitude Auto Selector ................ NORM
PREFLIGHT Passenger Temperature Selector ......... AUTO
Flight Deck Temperature Selector ........ AUTO
Exterior Safety Inspection ........... COMPLETE Zone Sys Fault Light ............ EXTINGUISHED
Crew Oxygen Masks .......................... CHECK Trim Air Switch ......................................... ON
Emergency Equipment ....................... CHECK Recirc Fan Switches ................................ ON
Maintenance Status............................ CHECK Aft Cargo Heat Switch .............................. OFF
Primary EICAS ...........CHECK, then CANCEL Equip.Cooling Selector..NORM, OVRD >21C
No Smoking Signs...................... ON / AUTO High Flow Switch...................................... OFF
Seatbelt Signs............................. ON / AUTO Pack Sys Fault Light............. EXTINGUISHED
Ground Tests Switch ............................ NORM Gasper Fan................................................ ON
Flight Control Shutoff Valves ................ NORM Cockpit Humidifier ................................... ON
Gen Field Man Reset Switches ............ NORM Pack Control Selectors...................... NORM
APU Field Man Reset Switches ........... NORM L and R Isolation Valve Switches.......... OPEN
Split System Breaker Switch ................ NORM APU Bleed Air Switch .............................. ON
Cockpit Voice Recorder Test....... COMPLETE Engine Bleed Air Switches...................... ON
Squib Test ................................... COMPLETE Radio Tuning Panel................ AS REQUIRED
EEC Maintenance Switches ................. NORM Weather Radar Panel............................... SET
De-fuel Panel......................CHECK AND SET Audio Control Panel ................................. SET
EEC Mode Switches............................. NORM HF and SELCAL..................................CHECK
IRS Mode Selectors.................................. OFF Data Printer Test ......................... COMPLETE
ATIS and Clearance ........................... OBTAIN
FMC Initialization:
IDENT Page .................... CHECK FMC Navigation Data:
Present Position ...............ENTER Route................ ENTER / CHECK
GMT ................................ CHECK Runway ............................ENTER
Flight Number...................ENTER SID .............. SELECT as required
Fuel Reserves .................. ENTER
IRS Mode Selectors ..............OFF, then NAV Cost Index ........................ ENTER
Standby Power Selector ....... BAT, then AUTO Cruise Altitude.................. ENTER
L and R Utility Power Switches...............ON Transitions........................CHECK
Bus Tie Switches .................................AUTO NAV Radios......... AS REQUIRED
Generator Contactors ..............................ON
Drive Disconnect Switches .......... NORMAL TCAS-System......................................... TEST
Hydraulic Demand Pump Selectors...... OFF Transponder Code ................................. SET
Hydraulic Engine Pump Switches ..........ON Transponder Mode ............................XPNDR
Hydraulic Quantity .............................. CHECK VOR/ADF Switches ................ AS REQUIRED
Fire/Overheat Test....................... COMPLETE Altimeter......................................... SET QNH
Emergency Exit Lights.....................ARMED TFC-Traffic Display .................................. ON
Observer Audio System Switch............ NORM ND Display Options ................ AS REQUIRED
Service Interphone Switch........................ OFF Flight Director........................................... ON
Cargo Fire Fwd / Aft Switches ...... DISARMED Autothrottle Arm Switch........................ OFF
Cargo Fire Discharge Switch............NORMAL Bank Limit Selector ............................... AUTO
MCP Heading and Altitude..................... SET
Autopilot Disengage Switch........................ UP BEFORE START CHECKLIST
Radar Altimeter................................... CHECK
Source Select Panel ................................. SET Hydraulic Demand Pump 4 ...................... AUX
Clock.................................... CHECK and SET Fuel Load and Pumps ............______ and ON
CRT Display Select Panel ........................ SET APU ............................................................ ON
PFD..................................................... CHECK Beacon .................................................. BOTH
ND....................................................... CHECK Doors.............................. CLOSED and AUTO
Standby Flight Instruments................. CHECK Passenger Signs .................... AS REQUIRED
Heading Ref Switch .............................. NORM
FMC Source Select ................................ LEFT Push Back ............................. AS REQUIRED
Primary EICAS ................................... CHECK Ground Signal ............................... RECEIVED
EICAS Status Display......................... CHECK Engines .............................................. START
Oil Quantity......................................... CHECK
Alternate Gear Extension Switches.......... OFF
Ground Proximity Panel............................ SET AFTER START
Speedbrake Lever ................................DOWN
Thrust Levers........................................... IDLE APU........................................ AS REQUIRED
Park Brake............................................... SET Hydraulic Demand Pump 4................. AUTO
Stab Trim Cutout Switches ............... CLOSED Pack Control Selectors (after 2 min) . NORM
Aft Cargo Heat Switch ............................. ON
FMC Takeoff Data: Engine Indications ............................ NORMAL
ZFW..................................ENTER Oil Quantity (after 30 sec) ...................CHECK
Gross Weight............... CONFIRM Nacelle Anti-Ice..................... AS REQUIRED
Thrust .............................SELECT Autobrakes..............................................RTO
Takeoff Flaps....................ENTER Flaps ...................................... SET TAKEOFF
Runway Conditions ..........ENTER STAB TRIM.............................................. SET
Takeoff Speeds ........... CONFIRM Rudder & Aileron Trims........................ SET 0
Trim CG....................... CONFIRM Flight Controls .....................................CHECK
Primary EICAS ..............RECALL and CHECK
MCP Speed.........................................SET V2 ACARS Off-Block Time ...................CONFIRM
APU ....................................... START/CHECK

PREFLIGHT CHECKLIST
AFTER START CHECKLIST
Battery Switch.............................................ON
Standby Power Switch........................... AUTO APU Selector.......................... AS REQUIRED
Packs.......................................................... ON
Hydraulic Demand Pumps........................ OFF
Park Brake ................................................ SET Recall/Status ..................................CHECKED
Landing Gear Lever..............................DOWN Ref Speeds.....................................CHECKED
Flaps....................................... AS REQUIRED
Flap Position Indicator and Lever....... AGREE
Fuel Control Switches....................... CUTOFF Trim .......................................................... SET
Anti-Ice...............................................NAI OFF Flight Controls ................................CHECKED
Autobrakes ...............................................RTO
Oxygen .......................................... CHECKED
Emergency Exit Lights........................ ARMED
Altimeters................................................. QNH
Taxi Lights ................................................ ON
TAXI OUT............................... AS REQUIRED
BEFORE START
BEFORE TAKEOFF
Flight Deck Door.............................LOCKED
Hydraulic Demand Pump 4 ................... AUX Cabin Report ................................. RECEIVED
Hydraulic Demd. Pumps 1, 2, and 3...AUTO Weather Radar ....................... AS REQUIRED
Fuel Quantity and Distribution ............ CHECK Autothrottle Arm Switch....................... ARM
Fuel Pumps .....................ON AS REQUIRED Transponder Code ..............................CHECK
Duct Pressure..................................... CHECK Transponder Mode ............................. TA/RA
LNAV ...................................... AS REQUIRED Transponder Bias..............................ABOVE
VNAV..........................................................ON Packs 2 & 3 ............................ AS REQUIRED
Pack Control Selectors 2 & 3 ............... OFF Exterior Lights ...................... AS REQUIRED
Beacon..................................................BOTH Elapsed Time ....................................... ZERO
BEFORE TAKEOFF CHECKLIST AFTER LANDING CHECKLIST

Vital Data ....................................... CHECKED Landing Lights & Strobes ......................... OFF
Packs ...................................... AS REQUIRED Flaps........................................................... UP
Cabin Crew..................................... NOTIFIED Speedbrake .......................................... DOWN
Weather Radar ......................................... OFF

AFTER TAKEOFF CHECKLIST SHUTDOWN

Landing Gear.............................................. UP Parking Brake ......................................... SET


Flaps ........................................................... UP Wing Anti-Ice ......................................... AUTO
Packs ..........................................................ON Nacelle Anti-Ice ........................................ OFF
Exterior Lights......................... AS REQUIRED Electrical Power.................... AS REQUIRED
Altimeters at TA ........................................ STD Stabilizer Trim...................................6 UNITS
APU .......................................................... OFF Rudder & Aileron Trims...................NEUTRAL
Hydraulic Demand Pump Selectors ..... OFF
T/C: Transponder Bias ................................N Fuel Control Switches ....................CUTOFF
T/D: Transponder Bias .....................BELOW Fuel Pump Switches .............................. OFF
Beacon .................................................... OFF
Seatbelt Signs......................................... OFF
APPROACH CHECKLIST Packs ..................................... AS REQUIRED
IRS Error .................................... DETERMINE
ATIS....................................................OBTAIN Transponder Code ................................... VFR
FMC Arrivals Procedure ......................ENTER EICAS Status Display .........................CHECK
Briefing......................................... COMPLETE Gear Brake Temperature ....................CHECK
Recall............................................. CHECKED IRS Mode Selectors................................ OFF
Altimeters at TL ....................................... QNH Speaker Volume.................................... OPEN
Vref ..................................................... ____kts Windshield Protection ........................... OFF
Minima ................................................. ______ Chocks ............................................ IN PLACE
Passenger Signs .................... AS REQUIRED Parking Brake......................... AS REQUIRED
Autobrakes ............................. AS REQUIRED
Landing Lights ............................................ON
SHUTDOWN CHECKLIST

Hydraulic Demand Pumps ....................... OFF


LANDING CHECKLIST Park Brake................................................ SET
Fuel Control Switches .......................CUTOFF
Speedbrake ........................................ ARMED Fuel Pump Switches................................. OFF
Landing Gear...................DOWN and GREEN External Power ....................... AS REQUIRED
Flaps ....................................... AS REQUIRED
Cabin Crew..................................... NOTIFIED

POWER-DOWN

AFTER LANDING Trim Air Switch ....................................... OFF


Recirc Fan Switches .............................. OFF
Autobrakes..............................................OFF Equipment Cooling Selector................. NORM
Autopilot ..................................................OFF High Flow Switch.................................... OFF
Transponder Mode .............................. STBY Gasper Fan.............................................. OFF
Exterior Lights ...................... AS REQUIRED Cockpit Humidifier ................................. OFF
Flaps .......................................................... UP Pack Control Selectors.......................... OFF
Speedbrake Lever...............................DOWN Exterior Lights ........................................ OFF
Weather Radar ......................................... OFF Emergency Lights .................................. OFF
Continuous Ignition................................ OFF L and R Utility Power Switches............. OFF
Flight Director .........................................OFF APU.......................................................... OFF
Autothrottle Arm Switch ........................ OFF Fire Detection Panel (after 2 min) .... NORMAL
APU ........................................ AS REQUIRED Interior Lights............................................ OFF
Equip.Cooling Select. .. NORM, OVRD if >21C Standby Power Selector ........................ OFF
Aft Cargo Heat Switch............................ OFF Battery Switch ........................................ OFF
WEIGHTS / Lbs WEIGHTS / Kg

Min Zero Fuel (ZFW) ......................... 397.000 Min Zero Fuel (ZFW) ......................... 180.076
Max Zero Fuel (MZFW) ..................... 535.000 Max Zero Fuel (MZFW)..................... 242.671
Max Taxi (MTW) ................................ 877.000 Max Taxi (MTW)................................ 397.800
Max Take Off Gross (MTOG) ............ 875.000 Max Take Off Gross (MTOG)............ 396.893
Max Landing (MLW) .......................... 630.000 Max Landing (MLW) .......................... 285.763
Max Payload....................................... 138.000 Max Payload......................................... 62.595
Min Landing Fuel, Domestic ................. 19.000 Min Landing Fuel, Domestic................... 8.618
Min Landing Fuel, International ............ 24.000 Min Landing Fuel, International............ 10.886

SPEEDS Limitations, IAS Flight Level Rules

Manual Landing Crosswind ......................... 30 < FL 290


Autoland Crosswind..................................... 25 0 to 179 Odd 2000 steps 3000 to FL 270
Autoland One Engine Crosswind .................. 5 180 to 359 Even 2000 st. 4000 to FL 260
Autoland Headwind ..................................... 25
Autoland Tailwind ........................................ 10 > FL 290
Autoland CAT III Crosswind ........................ 10 0 to 179 Odd 4000 steps from FL 290
180 to 359 Odd 4000 steps from FL 310
Max Turbulent Air Penetration >15000 ..... 290
Max Landing Gear, Extension ................... 270 One Way Routes
Max Landing Gear, Extended.................... 320 Any Course <FL 290 any card. >290 any Odd
Max Flaps Extension, Flaps 1 ................... 280

Flaps Up Stall Speed................................. 175


Full Flaps Stall Speed................................ 122
Landing Wind Rule

Vref plus steady headwind component plus


full gust wind component but not more than in
Flaps Extension Speeds, IAS total 20 kts.
Flaps 1 ..................................................... 280
Flaps 5 ..................................................... 260
Flaps 10 ..................................................... 240
Flaps 20 ..................................................... 230 FMC Examples
Flaps 25 ..................................................... 205
Flaps 30 ..................................................... 180 Cost Index, about ........... pax 100 / freight 250
Reserves (tons) ............ dom. 8.6 / intern. 10.9
Along Track Waypoint ..........PPPPP/20 or -20
Place Bearing/Distance............ PPPPP180/20
Place Bearing/PB ....... PPPPP270/PPPPP180

Autobrake Landing Distance

Autobrake Approach Speed - KIAS


Setting 120 130 140 150 160 170 180 190 200
1 6300 7200 8100 9100 10300 11400 12600 14000 15300
2 5400 6000 6800 7700 8600 9500 10500 11600 12600
3 4800 5300 6000 6600 7500 8300 9100 10000 10900
4 4000 4600 5000 5600 6200 6800 7600 8300 9000
Max Auto 3400 3800 4200 4600 5000 5500 6000 6600 7000

The distances are valid with or without reverse thrust and include 1200 ft of air distance.
Tailwind Adjustment per 10 Knots: Autobrake 1 +2050 / 2 +1650 / 3 +1400 / 4 +1100 / Max Auto +800

Anda mungkin juga menyukai