Guide
1. Setup port
mikroBootloader manual
2. Connect with MCU
mikroBootloader manual
UART bootloader for AVR microcontrollers
appropriate device firmware, which is free of charge and can to match your Connect button
be downloaded from mikroElektronikas website. configuration in within 5s. The chip
2 If your board utilizes UART communication over the FTDI MCU firmware. automatically enters
chip, it is necessary to install the appropriate driver for the Click OK to the Bootloader
operating system you use. Drivers may be downloaded at: proceed. mode and is
ready for further
http://www.ftdichip.com/Drivers/VCP.htm instructions.
your HEX on to
Opened: C:\Users\mmatovic.MIK\Desktop\
yy: 12
mikroBootloader final\led.hex
xx: 148
mikroBootloader xx: 0
yy: 0
window. Youll
yy: 12
that the file is Start bootloader by clicking on the Begin uploading button.
opened.
File: C:\Users\mmatovic.MIK\Desktop\mikroBootloader final\led.hex
The whole process is performed in two phases. Click on the
Show Activity button to view the operation of the bootloader.