Anda di halaman 1dari 2

Analogue Electronics II

Electronics II( ND)

1 - 1.1 Determine by experiment the output • Check the • Field affect transistors, bipolar transistors,
15 and transfer characteristics of FET connection of the voltmeter, ammeter, resistors, transistors cable,
1.2 Determine by experiment the d.c circuit made by veroboard, oscilloscope, frequency counter/meter
power dissipated by Class A, B, AB and students and stabilised power units
C amplifier • Ensure that the
1.3 Determine by experiment the power students follow the
efficiency of Class A, B, AB, and C instruction strictly
amplifiers
1.4 Perform experiment in investigate
the high frequency response of an
amplifier
1.5 Perform experiment to determine the
low frequency response of an amplifier
1.6 Perform experiment to investigate
the power output, power gain, efficiency
and non linearity operation of power
amplifier

Analogue Electronics III (HND 1)

PRACTICALS

Analogue(ELECTRONIC III) Laboratory Experiments


Week Specific Learning Outcome: Teachers Resources
Activities
1-4 1.1 Perform an experiment to determine the following parameters of an amplifier

a. Voltage gain
b. Current gain
c. Power gain

1.2 Perform experiment to determine the frequency response of an amplifier using


different loads.
1.3 Perform an experiment to illustrate different coupling methods in amplifier.
1.4 Perform experiment to illustrate the hybrid parameters.
5-8 Design and construction of Differential Amplifier
9 - 15 Design and construction of operational amplifier
Analogue Electronics IV (HND2)

WEEK EXPERIMENTS
1 1.1- Perform experiments to determine the effects on voltage gain, input and output impedance, bandwidth,
etc of negative feedback amplifiers.
2 1.2 Perform an experiment to illustrate the principles of operation of the oscillators in 2.3 above
3 1.3 Determine by experiments the characteristics of the oscillators in 2.3 above.
4 1.4 Perform experiment to illustrate the principles of:

a. Multivibration in 3.1 above


b. Schmidt trigger oscillators
c. UJT oscillators

5 1.5 Demonstrate practically, the various methods of stablised power supply in 4.10 above.
6 1.6 Determine by experiments the rectified output of a circuit with the following filters.

a. Capacitor input filter


b. Inductance input filter

7 1.7 Determine by experiment the output characteristics of a 3-phase rectifier.


8 - 10 1.8 Design and construct Feedback Amplifier
11 - 12 1.9 Design and construct Wien Bridge Oscillators
13 - 14 2.0 Design and construct Stabilized power supply unit

Anda mungkin juga menyukai