Ans-2
Ans-1
3.For adsorption of gas on solid ,a plot of log x/m vs Log P is linear with slop of
the equation equal to
Ans-4
4.In physical adsorption , gas molecules are bounded on the solid surface by
1)chemical force 2)electrostatic force 3)gravitational force 4)van der waal force
Ans-4
Ans-1
6.Which of the following is not correct regarding the adsorption of a gas on the
surface of solid
Ans-1
8.Adsorption is accompanied by
Ans-3
Ans-4
3)it is slow
4)it is irreversible
Ans-3
Ans-2
Ans-1
2)adsorption is spontaneous
Ans-1
1)the rate of dissociation of adsorbed molecules on the solid surface does not
depend on surface covered
2)the adsorption at single site on the surface may involve multiple molecules at
the same time
3)the mass of gas stricking the given area of surface is proportional to pressure
of gas
4)the mass of gas stricking the given area of surface is independent of the
pressure of gas
Ans-3
Ans-4
Ans-4
3)at initial stage where unimoleculer adsorption takes place & not after that
Ans-2
Ans-3
1)enthalpy is positive
2)entropy decreases
3)entropy increases
Ans-2
1)decrease in temp
2)increase in temp
3)decrease in pressure
Ans-1
22.Which of the following gas molecule will have maximum value of enthalpy
of physiosorption?
1)C2H6
2)Ne
3)H2O
4)H2
Ans- 3
Because
Ans-3
1)CO2
2)N2
3)CH4
4)Ar
Ans-1
25.During adsorption
1)TdS is positive
2)dH-TdS is negative
3)dH is positive
Ans-2
26.The volume of the gas H2, CH4 ,CO2 &NH3 adsorbed by 1g of charcoal at
288 K are in order
1)H2>CH4>CO2> NH3
2)CH4>CO2>NH3>H2
3)CO2>NH3>H2>CH4
4)NH3>CO2>CH4>H2
Ans-4
2)x/m=aP
3)x/m=1/aP
4)x/m=b/a
Ans-1
1)decrease in temperature
2)increase in temperature
3)decrease in pressure
Ans-1
Ans-1
4)noneof these
Ans-4
Ans-4
1)adsorption
2)sorption
3)absorption
4)desorption
Ans-1
1) adsorption only
2) absorption only
4)none
Ans- 3
Ans- 1)
---------------------------------------------------------------------------------------------------------
CATALYSIS-
2)nature of product
3)activation energy
4)equilibrium constant
Ans-3
1)heterogenous catalyst
2)homogenous catalyst
3)negative catalyst
4)positive catalyst
Ans-3
1)iodine powder
2)iron powder
3)manganese powder
4)activated charcoal
Ans-1
2)a catalyst remains unchanged in composition & mass at end of the reaction
Ans-3
5. Which of the following is characteristic of a catalyst ?
Ans-3
1)decreasing enthalpy
Ans-3
Ans-1
Ans-3
1)enzymes are specific bio catalyst that can normally function at a very low
temperature(about 100K)
2)enzymes are normally heterogenous catalyst that are very specific in action
Ans-4
Ans-4
4)urease is an enzyme
Ans-3
1)is zero
4)none
Ans-2
13.In petro chemical industry ,alcohols are directly converted into gasoline by
passing over heated
Ans-2
Ans-2,3,4
Ans-1,2,3
16.Zeolites are
1)enzyme catalyst
2)liquid catalyst
Ans-3
Ans-3
1)zymase 3)maltase
2)lactase 4)diatase
Ans-3
19.According to adsorption theory of catalysis ,the speed of the reraction
increases because
4.in the process of adsorption the activation energy of the molecules become
large
Ans-1
20.pick out the one which does not belong to the family ofenzumes.
a.lipaseb.pepsin
c.ptylind.cellulose
Ans-4
b.they have open structure which enable them to take up small molecules
d. some of the SiO4^-4 units are replase by AlO4^5- &AlO6^9- ions in zeolites
Ans-4
22.Enzyme are
4)synthesis catalyst
Ans-3
4)negative catalyst
Ans-2
24.InHabers process for synthesis of ammonia , the catalyst iron gets poisoned
by the following
Ans-3
25. In the esterification reaction of the acetic acid with ethyl alcohol , which of
the following acts as autocatalyst?
Ans-3
Ans-3
1)catalyst
2)enzyme
3)adsorbent
4)zeolites
Ans-4
Ans-3
4)all of these
Ans-3
2) its structure
Ans- 1)
1)crystalline
2)amorphous
3)both
4)none
Ans- 1)
1) PdCl2 or CuCl2
2) Ni
3)Pt
4) ZnSO4
Ans- 1)
1) Ni
2) Al2O3
3) Pt or V2O5
4) Mn
Ans-3)
--------------------------------------------------------------------------------------------------------