SERVICE MANUAL
Ver 1-2012E
l
Revision History
t i a
Area Lineup
fid
SVT13112FXS
SVT13113FXS
SVT13114GXS
US
SVT13116FXS
n
(United States)
SVT13118FXS
o
SVT131190X*
SVT1311EFYS
C
SVT13115FBS
PA SVT13115FDS
y
(Pan-America) SVT13115FLS
SVT131190S*
on
SVT1311C5E*
SVT1311M1ES
SVT1311M1RS
S
EU
(Europe)
SVT13113ENS
Design and specifications are subject to
AP
change without notice.
(Asia-Pacific)
,
,
PERSONAL COMPUTER
: CTO Model
9-890-907-01
Information in this document is subject to Caution Markings for Lithium/Ion Battery - The Service and Inspection Precautions
change without notice. following or similar texts shall be provided on
battery pack of equipment or in both the operating
Sony, VAIO and CLIE are trademarks or regis- and the service instructions. 1. Obey precautionary markings and 4. Inspect after completing service
tered trademarks of Sony. Microsoft, Windows, instructions
After servicing, inspect to make sure that all
Windows Media, Outlook, Bookshelf and other CAUTION: Danger of explosion if battery is
Labels and stamps on the cabinet, chassis, and screws, components, and wiring have been
Microsoft products are trademarks or registered incorrectly replaced. Replace only with the same
components identify areas requiring special pre- returned to their original condition. Also check
trademarks of Microsoft Corporation in the
or equivalent type recommended by the manu- cautions. Be sure to observe these precautions, the area around the repair location to ensure that
United States and other countries. The word
facturer. Discard used batteries according to the as well as all precautions listed in the operating repair work has caused no damage, and confirm
Bluetooth and the Bluetooth logo are trademarks
manufacturers instructions. manual and other associated documents. safety.
of Bluetooth SIG, Inc. AMD, the AMD logo, other
AMD product names and combinations thereof
are trademarks of Advanced Micro Devices, Inc. CAUTION: The battery pack used in this device 2. Use designated parts only 5. When replacing chip components...
Intel Inside logo, Pentium, Celeron and Core are may present a fire or chemical burn hazard if mis- Never reuse components. Also remember that
trademarks or registered trademarks of Intel Cor- treated. Do not disassemble, heat above 60C The sets components possess important safety the negative side of tantalum capacitors is easily
poration. Transmeta, the Transmeta logo, Crusoe (140F) or incinerate. Dispose of used battery characteristics, such as noncombustibility and damaged by heat.
Processor, the Crusoe logo and combinations promptly. Keep away from children. the ability to tolerate large voltages. Be sure that
thereof are trademarks of Transmeta Corporation replacement parts possess the same safety charac-
6. When handling flexible print
in the USA and other countries. Graffiti, Hot- teristics as the originals. Also remember that the
Sync, PalmModem, and Palm OS are registered
CAUTION: Changing the back up battery. mark, which appears in circuit diagrams and boards...
z Overcharging, short circuiting, reverse charg-
trademarks, and the Hotsync logo and Palm are parts lists, denotes components that have particu- z The temperature of the soldering-iron tip
ing, multilation or incineration of the cells must larly important safety functions; be extra sure to
trademarks of Palm, Inc. or its subsidiaries. (M) should be about 270C.
be avoided to prevent one or more of the fol- use only the designated components.
and Motrola are trademarks of Motrora, Inc. Other z Do not apply the tip more than three times to
lowing occurrences; release of toxic materials,
Motrola products and services with (R) mark like the same pattern.
release of hydrogen and/or oxygen gas, rise in
Dragonball are the trademarks of Motrola, Inc. 3. Always follow the original design z Handle patterns with care; never apply force.
surface temperature.
z If a cell has leaked or vented, it should be
when mounting parts and routing
All other names of systems, products and services wires Caution: Remember that hard disk drives are
replaced immediately while avoiding to touch
in this manual are trademarks or registered trade- easily damaged by vibration. Always handle
it without any protection.
marks of their respective owners. In this manual, The original layout includes various safety fea- with care.
the (TM) or (R) mark are not specified. tures, such as inclusion of insulating materials
(tubes and tape) and the mounting of parts above
ATTETION AU COMPOSANT AYANT
the printer board. In addition, internal wiring has
RAPPORT
The components identified by mark contain been routed and clamped so as to keep it away LA SCURIT!
confidential information. from hot or high-voltage parts. When mounting LES COMPOSANTS IDENTIFS PAR UNE
Strictly follow the instructions whenever the parts or routing wires, therefore, be sure to du- MARQUE SUR LES DIAGRAMMES
components are repaired and/or replaced. plicate the original layout. SCHMATIQUES ET LA LISTE DES PICES
SONT CRITIQUES POUR LA SCURIT DE
FONCTIONNEMENT. NE REMPLACER CES
COMPOSANTS QUE PAR DES PISES SONY
DONT LES NUMROS SONT DONNSDANS
CE MANUEL OU DANS LES SUPPMENTS
PUBLIS PAR SONY.
Sony Confidential
-- SVT131 Series (9-890-907-XX)
TABLE OF CONTENTS
Sony Confidential
-- SVT131 Series (9-890-907-XX)
CHAPTER 1.
BLOCK DIAGRAM
DDR3/3L DIMM1 DDR3/3L 1066/1333/1600 Channel B
1066/1333/1600 Intel CPU
Ivy Bridge 2C
RAM*1 RAM*1 DIMM0 (on board) BGA 1023 Pin
SFF
DDR3/3L 1066/1333/1600 Channel A
RAM*1 RAM*1
RAM*1 RAM*1
FDI DMI
13" LCD
RAM*1 RAM*1 at 5G
LVDS 1366x768
Connector RTC
ML1220_18mA
(Rechargeable)
2 CH
RTC HDMI HDMI
SPEAKER I NTEL
AUDI O CODEC PCH
RGB CRT CRT
Panther Point
Realtek
Headphone ALC269Q-VC2
HD Audio (Azalia)
USB2.0 USB 2.0 x1
INTERNAL MIC
4 USB 3.0 / 14 USB 2.0/1.1 ports
Charger IC USB 3.0/USB 2.0 x1
USB3.0 TPS2540A With charger function*1
ETHERNET (10/100/1000Mb)
High Definition Audio
SSD/HDD 2.5'' SATA CAMERA
(SATA0) SATA III Serial Peripheral I/F(dual output)
ACPI 1.1 USB2.0
LPC I/F TOUCH SCREEN
PECI
Mini Card SATA ports (6)
SATA III
SSD (mSATA)
PCIE ports (8)
Mini-Card
SMBUS NC WLAN/BlueTooth
Intel Jackson Peak
WB225
SPI
Sony Confidential
1- SVT131 Series (9-890-907-XX)
(END)
CHAPTER 2.
FRAME HARNESS DIAGRAM
WLAN ANTENNA
Front WLAN/BT
MIC CAMERA COMBO CARD AUX MAIN
2 BLK
LCD
GRY
CAMERA 1
MODULE
Top
LVDS CABLE
Extended
Memory
Model
Bottom
FFC (MB-TP)
FFC (MB-LEX)
Bottom
Bottom
BATTERY PACK
HDD/SSD
LEX-107
BOARD TOUCH PAD
SPEAKER Side A SPEAKER
SOCKET
(L) (R)
Top
Front
Button
WIRELESS
Note ...................................................................................3-2
Main Section T13112FXS MS-1 L-1 A-1
MS-1...........................................................................3-3 T13116FXS MS-1 L-1 A-1
LCD T13118FXS MS-1 L-1 A-1
US T13114GXS MS-1 L-1 A-1
L-1..............................................................................3-4
T13113FXS MS-1 L-1 A-1
Accessories
T1311EFYS MS-1 L-1 A-1
A-1............................................................................. 3-5 T131190X* MS-1 L-1 A-1
T13115FLS MS-1 L-1 A-1
T13115FBS MS-1 L-1 A-1
PA
T13115FDS MS-1 L-1 A-1
T131190S* MS-1 L-1 A-1
T1311M1ES MS-1 L-1 A-1
EU
T1311M1RS MS-1 L-1 A-1
Main Section LCD
T1311C5E* MS-1 L-1 A-1
AP
T13113ENS MS-1 L-1 A-1
: CTO Model
Sony Confidential
3- SVT131 Series (9-890-907-XX)
Note
Parts List is attached on the upper right portion of each EXPLODED VIEW. If there is the Remarks column in the parts list,
Items marked * are not stocked since they are seldom required for routine the features of applicable models are indicated in it
service. Some delay should be anticipated when ordering these items. for the parts that are different depending on each model.
The parts marked $ are the Reuse Parts.
For the abbreviations used in the remarks column, please refer to the <table 1>.
The parts marked with "&" indicates specific parts handling for Japan region.
, If "No-" is described on the left side of the Short-Name, it means 'not equipped'.
, Short-NameNo-
*CTO )No-BTNo-Felica
[***MBx2], [***MB], [***GBx2], [***GB] ,()or,
***MB/***GB: 1) BTFelicaWLAN BT, Felica, WLAN
x2: 2) BTFelica BT or Felica
x/sx,
,
RAIDHDD, HDD
,
,
,
! , !
,
,
Sony Confidential
3- SVT131 Series (9-890-907-XX)
MS-1. Main Section L-1 L-1
J I
Parts List
B2 Double-click on the paper clip mark to open the parts list.
B2 l
5 l ,
1 Extended l To open the parts list, Microsoft office Excel or Excel viewer is required.
Memory Model 25
A 25 3 l , Microsoft Office Excel Excel
(1)
B v1) When heat sink is removed from CPU, clean off the thermal grease
24 and put the Ref. No. 26.
D v1) CPU , , Ref. No. 26
B B2 11 A L-1
H
E 15
HDD +
mSATA SSD Model
B2
B4 C
G 7
B4 B2
F
B4
21
22
17
B5 B2 A
B4 20
B5
B4 B2 B2
B1
B5
B1
9 6
B B2 B2
C
L-1
D
B7
8
B2
D
B B2
L-1 B2
C
B8
E 14 A
B3
16 18 23
B6 B7 F B2
2 G
10
Sony Confidential
12 3- SVT131 Series (9-890-907-XX)
L-1. LCD Parts List
l Double-click on the paper clip mark to open the parts list.
l ,
l To open the parts list, Microsoft office Excel or Excel viewer is required.
l , Microsoft Office Excel Excel
106
MS-1
D
104
B6
B2
102
B10
108
105 B6
101 103 MS-1
C
L-1 B2
110
H 109
107
L-1
J
L-1
I
B10
B9
111
Sony Confidential
3- SVT131 Series (9-890-907-XX)
A-1. Accessories Parts List
2008 2019
AC Power Cord Power Cord Set
Sony Confidential
3- SVT131 Series (9-890-907-XX)
(END)
SVT131 Series (US/PA/EU/AP)
, ,
, ,
English / Japanese
Sony Corporation 2012E2700-1
2012 Sony Corporation
9-890-907-01 - 11 - Published by Sony Corporation VAIO & Mobile Business Group CS & Quality Div. VAIO Global CS Dept.
Revision History
Suffix Ver. Date Contents QM No.
-01 Ver. 1 2012.05.11 First Edition -
<Remarks>
537
[Sony Confidential]
SVT131 Series (9-890-907-XX)