Report Contents
Design 1___________________________________________________________________________________________________ 2
Scenario 1 ................................................................................................................................................................................................ 2
Materials ............................................................................................................................................................................................. 2
boundary conditions ..................................................................................................................................................................... 3
Initial Conditions ............................................................................................................................................................................ 3
mesh ..................................................................................................................................................................................................... 4
Physics ................................................................................................................................................................................................. 5
Solver Settings .................................................................................................................................................................................. 6
Convergence ...................................................................................................................................................................................... 6
Results ................................................................................................................................................................................................. 7
Design 1
Length units meter
Coordinate system Cartesian 3D
SCENARIO 1
MATERIALS
BOUNDARY CONDITIONS
TYPE ASSIGNED TO
Slip/Symmetry Surface:163
INITIAL CONDITIONS
TYPE ASSIGNED TO
MESH
Automatic Meshing Settings
Surface refinement 0
Gap refinement 0
Resolution factor 1.0
Edge growth rate 1.1
Minimum points on edge 2
Points on longest edge 10
Surface limiting aspect ratio 20
Meshed Model
PHYSICS
Flow On
Compressibility Incompressible
Heat Transfer Off
Auto Forced Convection Off
Gravity Components 0.0, 0.0, 0.0
Radiation Off
Scalar No scalar
Turbulence On
SOLVER SETTINGS
Solution mode Steady State
Solver computer LOCAL
Intelligent solution control On
Advection scheme ADV 1
Turbulence model k-epsilon
CONVERGENCE
Iterations run 100
Solve time 326 seconds
Solver version 16.0.20150322
Energy Balance
Mass Balance
IN OUT
Mass flow 2.03108 kg/s -2.00851 kg/s
Volume flow 1.685912 m^3/s -1.66718 m^3/s
RESULTS
Decision Center