The Pull Cord Switch is installed at the side of belt conveyor and
connected with cord along all long of the conveyor. When an emergency
case occurs, the worker can stop the belt conveyor at any position by
pulling the cord, which drives the actuating arm rotating. Thru mechanism
transmission, rotatory actuating arm will finally drive cam and activate the
Micro-Switches. Micro-switches will OPEN (cut off) the control circuit and
stop the belt operation. When the operating lever is pulled to the angle of
30 , it would be latched. Manual reset is required. Display board will be
upright while Pull Cord Switch is operating for easy recognition
Plastic Coated Steel Tension Spring Cord Anchor Hook Cord Clamp Mounting Bracket
Wire Cord Type: RH003 Type: TH009 Type: SK001 Type: ZJ004
Type: RS03/04 Specification: 140*20*3mm Specification: 185*7.2mm Specification: 4# Specification: 150*210*110mm
Specification: 3/4mm Remark: Galvanized Carbon Remark: Galvanized Remark: Galvanized Remark: Galvanized Carbon
Remark: Red Steel/SUS304 Carbon Steel Carbon Steel Steel
Qty: 60M/Switch Qty: 2PCS/Switch Qty: 20PCS/Switch Qty: 6PCS/Switch Qty: 1PC/Switch