Notes: Please read this manual carefully before using our access control system!
1. Introduction
Suitable elevator: Passenger elevator, cargo elevator, home elevator or any other types of
2. Usage
(1) Card/password identification mode: put a registered care in front of the sensor (or
enter the password) and select the terminal floor on the COP within 20 seconds after
identification.
(2) Card and password identification mode: enter the password within 10 seconds after
2/9
Shanghai Guotai Elevator Co., Ltd. IC Card Access Control System
indentifying a registered card, and then select the terminal floor within 20
seconds.
3. Specification
Item Parameter
Dimension 116mm116mm20mm
Weight 130g
3/9
Shanghai Guotai Elevator Co., Ltd. IC Card Access Control System
LED Light:
Identified Card on
Unidentified Card on
Unlocked on
Password mode on
Setting mode on
Setting Accepted on
Beeper:
Meaning Sound
4/9
Shanghai Guotai Elevator Co., Ltd. IC Card Access Control System
5/9
Shanghai Guotai Elevator Co., Ltd. IC Card Access Control System
5. Setting
Enter
* Admin password #
(3)Setting
Enter:
# *
Enter:
6/9
Shanghai Guotai Elevator Co., Ltd. IC Card Access Control System
serial number # *
Notes
A. Card serial number should be set between 001 and 999. Every registered card should
B. If the administrator wants to register more than one card, then please continue to
repeat the Identify an unregistered card Enter a card serial number process, after
entering the first card serial number. When all the cards are registered, please enter #
7/9
Shanghai Guotai Elevator Co., Ltd. IC Card Access Control System
8/9
Shanghai Guotai Elevator Co., Ltd. IC Card Access Control System
If the admin password is forgotten, please use the RESET switch on the
main board to reset the system and get the default setting. Please turn off the power at
first and set the RESET JUMPER to ON mode, then turn on the power and set the
NOTES: During any setting process, the Maximum time between pushing 2
buttons is 10 seconds.
9/9