0030 X Welder Qualification Records & Repair Rate Tracking SAES-W-011 and/or W-012 and ASME IX.
0040 X Weld Procedure Qualification Records, Weld Procedure SAES-W-011 and/or W-012 and ASME IX. Company approval
Specifications and Weld Table required.
0050 X NDT Personnel and Procedures Verify valid personnel qualification and approved procedures.
0020
0010
***
X
In process inspection & test requirement
Weld Joint Preparations
Specification Details / Notes:
01-SAMSS-010 & SAES W-011 or 012 as required
0030 X Full Penetration Welding achieved on 2" or Smaller Weld Bosses 01-SAMSS-010 & SAES W-011 or 012 as required.
0040 X Visual Weld Inspection & Workmanship 01-SAMSS-010 & SAES W-011 or 012. Shall be performed
prior to NDT.
0050 X Post Weld Heat Treatment (if required) 01-SAMSS-010 & SAES W-011 or 012. Shall be performed
prior to final NDT.
0060 X X Impact test and Hardness test(if required) Per applicable standard.
0080 X X NDT Per 01- SAMSS-010 , SAES W-011 or 012 and applicable
standard
0030 *** Final inspection & test requirements Specification Details / Notes:
IR013100 Continued...
INSPECTION & TESTING REQUIREMENTS REVISION: 11/03/2011 CODE NUMBER: PAGE:
SAUDI ARAMCO FORM-175 REPLACES: 05/09/2011 IR013100 2 of 2
(1) VISUAL INSPECTION WITNESSING BY INSPECTOR (Note 1)
(2) CERTIFICATES / RECORDS TO BE CHECKED BY INSPECTOR
(3) CERTIFICATES / DATA TO BE PROVIDED BY VENDOR / SUPPLIER / MANUFACTURER
0010 X X Visual and Dimensional Inspection and Verification of Marking Per 01-SAMSS-010 and PO requirement
0020 X Hydrostatic Test (if required) Per 01-SAMSS-010, code and PO requirement.
0040 X Marking, Spool Identification, cleaning, End Protection and Per 01-SAMSS-010, Codes and PO requirement.
shipment
Notes:
(1) May only be waived by the responsible Saudi Aramco, ASC, AOC Inspection Offices.
(2) See form SA175 - 000003 for instructions on using this form.
(3) Extent of witnessing shall be decided during the pre inspection meeting
End of IR013100