Department
ADVANCED DIGITAL SIGNAL PROCESSING
GENERAL INSTRUCTION:
1. Modify the m-file shown below to study the operation of a factor-5-up-sampler and factor-6-up-
sampler on the following input sequences: (a) sum of three sinusoidal sequence of normalized
frequencies 0.3, 0.5 and 0.75 rad/sec, (b) ramp sequence and (c) Square wave sequence with
varying duty cycles. Choose input length of 100.
Electrical and Electronics Engineering
Department
2. Modify the m-file shown below to study the operation of a factor-5-up-sampler and factor-6-up-
sampler on the following input sequences: (a) sum of three sinusoidal sequence of normalized
frequencies 0.3, 0.5 and 0.75 rad/sec, (b) ramp sequence and (c) Square wave sequence with
varying duty cycles. Choose input length of 100.
3. The m-file below creates a band-limited sequence and plot the spectrum of the sequence.
Generate the spectrum if the sequence is to be (a) down-sampled by a factor of 2 and (b) up-
sampled by a factor of 5. What happen? Describe the resulting spectrum.