Installation Instructions
1 INTRODUCTION
This document provides the installation instruction for the MAGLINK I/O system.
2 INSTALLATION STEPS
In order to permits the correct functionalities of the MAGLINK I/O, the connections to be perform are:
• The RS-485 communication interface between the “MAGLINK LX” and the “MAGLINK I/O”.
The connection points are report in the following figure. The “BARRIER” board is shown:
The fuses F1, F2 and F3 could be substitute, in case of breakage, with an equivalent P/N fuse:
F1 1.6A 021601.6MXP
F2 100 mA 0216.100MXP
F3 100 mA 0216.100MXP
This document is property of START ITALIANA srl. Unauthorised reproduction or distribution is not permitted Page 1 of 3
MAGLINK I/O
Installation Instructions
• the jumpers used to set the Normally Closed (NCx) or Normally Open (NOx) relay configuration
• A jumper positioned in
o NO1 position : the relay contacts are normally OPEN and are CLOSED if the relay is activated
o NC1 position : the relay contacts are normally CLOSED and are OPEN if the relay is activated
This document is property of START ITALIANA srl. Unauthorised reproduction or distribution is not permitted Page 2 of 3
MAGLINK I/O
Installation Instructions
The status of these inputs are acquired and printed by the MAGLINK LX console
The fuses F1 and F2 could be substitute in case of breakage, with an equivalent P/N fuse:
F1 100 mA 0216.100MXP
F2 100 mA 0216.100MXP
This document is property of START ITALIANA srl. Unauthorised reproduction or distribution is not permitted Page 3 of 3