Short-circt
Technical information
protection diagrams to UL 508
‘The short-circuit resistance of Fital FiLine6O
has been extensively tested. Shor-crcut
fesistance to UL entera i asseseed va tho
feotmean-square value of he short-cicut
Curent (ims), which must be applied for at
Teast 3 periods (60 m3),
During the course of testing, the tet equip
‘ment has been adjusted othe respective
‘ockmean-sauare values (Is). The test
‘ant pak shoreircut euronts Ip are shown
inthe shortsieut protection diagrams
below
Busbar support
for feeder circuits 700A, 2-pole
Sattogue $9 page 278
Sottings ln (lof te test equipment
without prostuse:
Sapa spesre 7 Tipper apg ing
60 mm bar centre distance, is is fi me
for busbare 128 20% 10 mm, 20 S 20 =
Note: 500 25 0 z
'SV'9940.050 with E-Cu 0 x 5/10 mm
Wiha pre-us, fe oloning short-cut sv 9240.050 sv 240.050
‘ale can be achieved wath 205/10 mm vith 25% 5mm
‘Suppor spacing” $60 mm Box shiomm
Fuse, Clase L880 isxansmn
Ie: 608A z a
Fe Fo!
Es E.|
ie i:
Busbar support Setings Ini) of he test equipment
for feeder circuits vwthout prfuse
POMS eoytso0 a rs 100, SETS a a =
Gliaiogue-33, page 278279 = “ — =
60 mm bar cate distance 50 it a0 zB
{or PLS special busbars,
Note:
‘SV 9342.050 (PLS 1600)
With pre-use, the folning short-circuit
value can be achieved:
eSupport spacing: 250 mm
~ Fuses tO
ays: 65 KA
li 65
‘SV 9341 080 (PLS 800)
af
reorder
‘SV 9342.080 (PLS 1600)
Fital Catalogue 33Poverdstrbuion