0 penilaian0% menganggap dokumen ini bermanfaat (0 suara)
155 tayangan4 halaman
This document contains a table listing parameters for a wireless network. It includes 20 parameters with statuses of ordinary, critical, or prohibited. The counts range from 1 to 3864. The comments provide details on adjustments being made to thresholds, timers, and configuration settings.
This document contains a table listing parameters for a wireless network. It includes 20 parameters with statuses of ordinary, critical, or prohibited. The counts range from 1 to 3864. The comments provide details on adjustments being made to thresholds, timers, and configuration settings.
This document contains a table listing parameters for a wireless network. It includes 20 parameters with statuses of ordinary, critical, or prohibited. The counts range from 1 to 3864. The comments provide details on adjustments being made to thresholds, timers, and configuration settings.
ASSRETRYMAX Critical 3864 changing from 1 to 3 CELLMAXSD Ordinary 35 increasing by 8 DELAYSENDRFCHREL prohibited 76 decreasing to 500 DIRECTRYEN Critical 1548 enabling DRTAGCELLSEL Ordinary 3945 setting to YES FMSMAXOPCC Critical 106 from 5 to 0 and from 0 to 5 IDLESDTHRES Ordinary 12 from 2 to 6 IMMASSRESENDEN Ordinary 2216 setting to YES LOADSTATYPE Ordinary 1523 from DYNPDCHASIDLE to DYNPDCHASOCCUPY MSMAXRETRAN prohibited 2573 setting to 1 SATimerOptSw Critical 3934 setting to ON TCHBUSYTHRES Ordinary 51 reducing TCHTRIBUSYUNDERLAYTHR Ordinary 756 reducing TCHTRICBUSYOVERLAYTHR Ordinary 654 reducing VOICEVER n/a 1 Load threshold for assigning half rate channels preferentially. If the current TCH seizure ratio of the cell is greater than or equal to this thres Maximum number of reassignments after the air interface assignment fails. If this parameter is set to a large value, the call completion rate Maximum number of SDCCHs in a cell. Before initiating dynamic conversion from TCHs or dynamic PDCHs to SDCCHs in a cell, the BSC chec Timer for delaying a connection release. This parameter is used for delaying the channel deactivation after the active signaling link is broke Whether to enable a directed retry. The directed retry is to hand over an MS to a neighboring cell in the same procedure as the handover. T Whether directed retry can be performed to multiple target cells. When this parameter is set to "YES", directed retry can be performed to m Maximum transmit power level of MSs. As one of the cell reselection parameters in system message 3, this parameter is used to control th Threshold of idle SDCCHs in a cell. When the number of idle SDCCHs in a cell is smaller than or equal to the threshold, the BSC attempts to Whether the BSC sends immediate assignment retransmission parameters to the BTS Whether to consider the dynamic PDCHs that have been converted into PDCHs when the BSC calculates cell load. Maximum number of Channel Request messages that can be sent by an MS in an immediate assignment procedure. Whether to enable the SACCH multiframe counter optimization function. If this parameter is set to ON, the BTS starts the SACCH multifram If the current channel seizure ratio reaches or exceeds this value, the half-rate TCH is assigned preferentially; otherwise, the full-rate TCH is Threshold for determining that the underlaid subcell is busy. The BSC assigns channels in the overlaid subcell to the MS in a concentric cell. If the channel seizure ratio of overlaid subcell is greater than Speech version supported by a cell. ds the BTS an RF CHAN REL message. on. If the directed retry always occurs in some areas of a network, consider adjusting the sector and TRX configuration and the network layout. on and the network layout.