ASSIGNMENT – 3
Topic: Analysis and Design of beams by Limit State Method
1) Determine the anchorage length of 4-20T reinforcing bars going into the
support of the simply supported beam shown in the figure below. The
factored shear force Vu = 280 kN, width of the column support = 300 mm.
Use M 20 concrete and Fe 415 steel.
Assume M20 grade concrete, Fe 415 grade steel and an effective cover of 40
mm from each face.
10) A simply supported beam 300 mm wide and 600 mm effective depth carries
a uniformly distributed load of 74 kN/m including its own weight over an
effective span of 6 m. The reinforcement consists of 5 bars of 25 mm
diameter. Out of these, two bars can be safely bent up at 1m distance from
the support. Design the shear reinforcement for the beam.