1
SETTING UNITS, LIMIT AND PAPER SIZE
1. Objective(s):
3. Discussion:
• Units is a command that can controls the encoding of actual paper measurements for linear and
angles that could be set as a constant value including the number of decimal places that will be
used for CAD dimensioning procedure.
• In exception with that, this format can be used with any basic unit of measurement such as decimal
mode which applicable for any measurement system unit.
• To compute for the size of the paper multiply the paper size with the plotting scale ( Paper Size X
Plotting Scale).
• For the onscreen paper size, Grid Extents should be used. (Using limits command for
modification of grid that will be extents)
• Bounding Objects (The paper can be created by using rectangle, corner pts., line and etc.
commands)
• Limits is use for the pre-scale of the drawing model of the electronic file.
Note: The importance of setting the grid limits is to enables the user upon completing the object
that will fit on the paper specified space.
4. Resources:
AUTOCAD Software
Laboratory Manual
5. Procedure:
9
Units - Using the command bar type un then press enter key
Limits - Using the command bar type limit/s then press enter
Grids and Snap Spacing - Using the command bar type Grid then press enter
Then at the command prompt type the value of 100 then press enter
Note: That variable 100 is the desired spacing between each grid points.
1. Using the command prompt type snap then press enter
2. Then at the command prompt type the value of 8 then press enter (the variable 8 is the desired
snap spacing point.)
10
Date Performed: Date Submitted:
Instructor:
6. Activities:
Analyze the given figure by applying the units, grid, and limits commands and identify the unit
measurement, grid, and paper size limit.
7. Conclusion:
11