ETG 1000 model features PFC ( Pow wer Factor Co orrector) circcuit on powerr supplies
input in order
o to reduc
ce below limiit values firstt 40 current harmonics
h emmission, as
requestedd by technical european diirectives (EN6 61000-3-2). Thanks
T to thiss device
electronicc equipmentss better prote
ected from diisturbs when connected to o the
mains.
• Photos
• Highlights
• Audio quality
• High Performance
o Reliability: RF amplifier is protected by a VSWR monitor
progressively reducing output power to a safe value in
the case of mismatch; ETG exciters can be run in this
condition indefinitely without risks of damage.
o Stability: an ALC circuit ensures that output power
remains constant throughout the operating frequency
band.
o Telemetry: Standard included in basic equipment,
allows remote monitoring and adjustment of the unit's
operating parameters. Just an additional standard or
GSM modem or HyperTerminal software (© Microsoft
Windows) is required.
o Modularity: An expansion slot has been designed to
place a Stereo Input and Stereo coder board (stereo
filetr, clipper and pre-emphasis) inside ETG exciters.
• Technical Features
GENERAL FEATURES
Operating band: 87.5 ÷ 108 MHz
Frequency step: 10 kHz
F3 direct frequency modulation
Modulation type:
of VCO
Power amplifier technology: MOSFET
Nominal power: 1000 W
Output power stability: +/- 0.1 dB
Output Impedance: 50 Ohm
RF output connector: "N" Female, 7/16", LC, 7/8"
Harmonic and spurious attenuation:< -80 dBc
Frequency stability: within 1 ppm
asynchronous 0.1% ( typ.);
Residual AM:
synchronous 0.2% ( typ.)
Dimensions: 48.5L X 45.5D X 13.5H cm
Weight: 22 Kg
Power supply voltage: 115 / 230 VAC singlephase
Power Consumption : 1600 VA typ. @ 1000 W RF
Cooling System: Forced air-cooling
ENVIRONMENTAL CONDITIONS
Operating conditions temperature: 0°C ÷ +45°C
Non-operating conditions temperature:-20°C ÷ +50°C
Operating conditions humidity: 95% @ +40°C
Non-operating conditions humidity: 90% @ +65°C
Operating conditions altitude: < 4600 m. s.l.m.
Carrying altitude: < 15.000 m. s.l.m.
MPX INPUT
Impedance: 10 kohm unbalanced input
Frequency response: ± 0.1 dB (30 Hz ÷ 100 kHz)
0.05% two-tones 1kHz and 3 kHz
Intermodulation distortion:
measurements
THD+N: < 0.03% @ 1 kHz
better than 72dB referred to
S/N CCIR:
75kHz
Connector type: BNC female
SCA INPUT
Input Impedance: 10 kOhm unbalanced input
Connector type: BCN female
ENVIRONMENTAL CONDITIONS
Operating conditions temperature: 0°C ÷ +45°C
Non-operating conditions temperature:-20°C ÷ +50°C
Operating conditions humidity: 95% @ +40°C
Non-operating conditions humidity: 90% @ +65°C
Operating conditions altitude: <4600 m s.l.m.
Carryng altitude: <15000 m s.l.m.
The above details are referred to ETG1000 model.