org/portland-cement-flexural-strength/
Flexural strength is typically used in PCC mix design for pavements because it best simulates slab flexural stresses as they are subjected to
loading. Because the flexural test involves bending a beam specimen, there will be some compression involved, and thus flexural strength will
generally be slightly higher than tensile strength measured using a split tension test. Usually, mix designs are typically tested for both flexural and
compressive strength; they must meet a minimum flexural strength, which is then correlated to measured compressive strengths so that
compressive strength (an easier test) can be used in field acceptance tests.
There are two basic flexural tests: the third-point loading (Figure 1) and the center-point loading (Figure 2). For maximum aggregate sizes less than
50 mm (2 inches), each test is conducted on a 152 x 152 x 508 mm (6 x 6 x 20 inch) PCC beam (see Figures 3 and 4). The beam is supported on
each end and loaded at its third points (for the third-point loading test) or at the middle (for the center-point loading test) until failure. The modulus of
rupture is then calculated and reported as the flexural strength. The third-point loading test is preferred because, ideally, in the middle third of the
span the sample is subjected to pure moment with zero shear (Mindess and Young, 1981[1]). In the center-point test, the area of eventual failure
contains not only moment induced stresses but also shear stress and unknown areas of stress concentration. In general, the center-point loading
test gives results about 15 percent higher (ACPA, 2001).
1 of 2 3/27/2018, 11:15 AM
Portland Cement Flexural Strength | Pavement Interactive http://www.pavementinteractive.org/portland-cement-flexural-strength/
Figure 3. Beam Test Specimen for Flexural Tests Figure 4. Casting Flexural Beam Test Specimens in
the Field
AASHTO T 177 and ASTM C 293: Flexural Strength of Concrete (Using Simple Beam with Center-Point Loading)
2 of 2 3/27/2018, 11:15 AM