Elmes I Uts 2013 - 029
Elmes I Uts 2013 - 029
The shaft shown in the figure, is driven by pulley B from an electric motor. Another belt drive from
pulley A is running a compressor. The belt tensions for pulley A are 1500 N and 600 N. The ratio of belt
tensions for pulley B is 3.5. The diameter of pulley A is 150 mm and the diameter of pulley B is 480
mm. The allowable tensile stress for the shaft material is 170 MPa and the allowable shear stress is 85
MPa. Find the shaft diameter by: (a). Maximum shear stress theory, (b). Maximum distortion energy
theory.
B
1AI
Single riveted lap joint of 8 mm plates with 22 mm diameter rivets having a pitch of 55 mm. Assume:
Permissible tensile stress in plate = 120 MPa
Permissible shearing stress in rivets = 90 MPa
Permissible crushing stress in rivets = 180 MPa
Find the efficiency of this riveted joint ?
Sebuah kopling plat gesek banyak diperlihatkan seperti pada gambar. Apabila diketahui jari-jari luar
dan dalam plat gesek adalah 150 mm dan 50 mm, koefisien gesek p = 0.15 dan gaya tekan P = 500 N,
hitunglah:
a) . Torsi yang bisa ditransmisikan, dengan asumsi tekanan seragam ?
b) . Torsi yang bisa ditransmisikan dan tekanan kontak rata-rata pada permukaan gesek, dengan asumsi
keausan seragam ?
c) . Apabila dikehendaki hanya menggunakan plat gesek tunggal dengan jari-jari dalam plat gesek tetap
50 mm, hitunglah jari-jari luar plat gesek yang dibutuhkan dengan asumsi tekanan seragam ?
D fC