Management System
During Operation
Inspect for oil, water, or fuel leaks and unusual smells or noises O O O O O O O ...................................... ...............................
Grease – in accordance with manufacturer’s instructions O O O O O O O ...................................... ...............................
Are the holes properly sealed by the rubber skirt? O O O O O O O ...................................... ...............................
Is the dust extraction equipment fully operational? O O O O O O O ...................................... ...............................
At end of shift
Drain the air tanks O O O O O O O ...................................... ...............................
General
Are there any obvious signs of cracks, overhangs on/behind the face? O O O O O O O 7 = stop and seek advice ...............................
Is the brake operational? O O O O O O O ...................................... ...............................
Is your shelter up wind of the rig? O O O O O O O ...................................... ...............................
Is the compressor on level ground? O O O O O O O ...................................... ...............................
Weekly
Seat and seat belt condition (where applicable) O O O O O O O 7 = stop and seek advice ...............................
S19 – Drill Rig & Compressor Inspection Checklist H&SM&I10 - 1 / 1 Produced in association with The Institute of Quarrying
Issue 1 : Revision 1 - September 2012 © QMJ Publishing Ltd