temperature. High temperatures, above 40 ° C, generate degradation of the enzymes and this is
critical for cellular performance. Microorganisms have an optimal level of growth and
metabolism within a well-defined temperature range. Besides the temperature has a profound
effect on the transfer rate, it influences the pH - alkalinity and solubility of the gas, and solids
sedimentability. The author of this article asserts that the efficiency of the process decreases
below 15 ° C since the purification is due mainly to sedimentation, whereas above 15 ° C the
biodegradation increases. The efficiency of the anaerobic process is highly dependent on the
reactor temperature. Temperature changes in the mesophilic range can normally be tolerated, but
when the temperature falls the load must also be decreased according to the decrease in the
expected activity
electricity and low environmental impact. The International Energy Agency, estimates that by
2050, at the global level, Biofuels will account for 27% of the total transport fuel, avoiding Gt of
CO2 emissions per year, as long as they are produced in a sustainable way. This article contend
that the main components for the conversion of waste into energy are: (i) Solid waste prepared as
an essential input; (ii) the plant; and (iii) the mechanisms Necessary to connect it to the backbone
of electrical energy. Within this scale, some technologies can identify levels of waste
composition by minimizing the pre-treatment steps in order to convert them into fuels. Pre-
treatments require energy as part of the waste assessment process; so the technology to be
selected must tie with the physical properties and the average impact of the landfill in order to
minimize costs. The author of this article firmly believe that the efficiency of the processes of
converting waste into energy the most common form of generating energy is the generation of
hot gases from receptacles where through boiling water, agitation and subsequent cooling,
Produce vapor and gases that are separated. Through the ducts and turbines the gases are
Transport electric or synthetic natural gas generators. Part of the electricity Produced is used to
supply power to the plant, the rest is transported to the Energy backbone to be used for a variety
pumping system, or ground or underground transport. This article asserts that the separation
process of the waste is more complex than the normally known process and the preparation of
compost. In principle, for a good separation of bacteria there must be a careful control of
moisture levels, microbial consortia suitable for the type of waste and sensitive to the type of
waste to be processed.