Instruction: Candidates should read carefully the instructions printed on the question paper and on the
cover of the Answer Book, which is provided for their use.
NB:
1) Question No.1 is compulsory.
2) Out of remaining questions, attempt any four questions.
3) In all five questions to be attempted.
4) All questions carry equal marks.
5) Answer to each new question to be started on a fresh page.
6) Figures in brackets on the right hand side indicate full marks.
7) Assume Suitable data if necessary
Q.2 (a) Explain Rapid prototyping technique with neat sketch. [6M]
Q.3 write a manual part program for machining the component shown in figure. Assume spindle speed
as 200rpm and feed rate as 0.5 mm/rev. [12M]
Q.4 (a) consider a triangle ABC having coordinates A(5,5)B(8,5)C(5,10).determine new vertex position
positions if (i) the triangle is rotated by 600 anticlockwise about vertex A. (ii) the triangle is scaled by
2times in X direction and 3times in Y direction about vertex A. [6M]
Q.5 (a) Explain Generative type Process planning and its benefits. [6M]
Q.6 (a) write 3D transformation matrix for translation, scaling and rotation about X-axis (YZ plane),Y-
axis(ZX plane) and Z-axis(XY plane). [6M]
(b) ) Fit a Cubic Bezier curve for the control points (2,2),(2,3), (3,3)and (3,2).Find the equation of the
Bezier curve. [6M]
a) Graphics Standards
d) NC coordinate Systems
e) Bill of Materials