in pump PC control circuit 1 Measuring and adjusting tools for oil pressure in pump PC control circuit Symbol Part No. Part name 799-101-5002 Hydraulic tester 1 790-261-1204 Digital hydraulic tester L 799-101-5220 Nipple (10 × 1.25 mm) 2 07002-11023 O-ring
Stop the machine on a level ground and
lower the work equipment to the ground. 2) Install nipples L2 and nipples [1] of Then, release the residual pressure from hydraulic tester L1 and connect them to oil the hydrauli c cir cuit. For detai ls, see pressure gauges [2]. “Releasing residual pressure from hydrau- Connect the measuring part of plug lic circuit”. (3) by using joint (790-301-1271) and elbow (790-301-1530) of hydraulic Measuring tester L1 and nipple [1] so that it will Before measuring the oil pressure in the PC not interfere with the drain piping. control circuit, check that the oil pressure in the Use the oil pressure gauge of 60 MPa work equipment, swing, and travel circuits and {600 kg/cm2}. the control circuit source pressure are normal. Measure the oil pressure in the pump PC con- trol circuit under the following condition. Hydraulic oil temperature: Within operating range
1. Measuring of PC valve output pressure
(servo piston inlet pressure) Measure the PC valve output pressure (servo piston inlet pressure) and pump discharge pressure simultaneously to compare them. 1) Open the side cover of the pump room and remove oil pressure pickup plugs (1), (2), (3), and (4). 3) Start the engine and operate the arm cyl- (1): Front pump discharge pressure inder to the IN stroke end. pickup plug 4) Set the working mode in the power mode (2): Rear pump discharge pressure (P) and turn the swing lock switch ON. pickup plug If the swing lock switch is turned ON, (3): Front PC valve output pressure the main relief valve is set for high- pickup plug pressure relief. (4): Rear PC valve output pressure pickup plug