QUESTION BANK
EDA
The point where increasing vdd voltage has no effect in Idd current is called
a. Pinch off.
b. cut off.
c. break down
D-mosfet works
a. With Gate voltage present.
b. With out gate voltage.
c. with Drain to source voltage.
Page 1 of 2
d. with drain to source voltage set to maximum.
N-channel E-Mosfet
a. Gate voltage is +ve.
b. Gate voltage is –ve.
c. Gate voltage is connected to ground.
d. Gate is floating.
Which type of biasing, source does not have resistor connect to it in Jfet.
a. Self bias.
b. Fixed bias.
c. Potential divider.
d. No Biasing.
Efficiency of amplifier is
a. Ratio of output power to input power.
b. Ratio of output power to DC power.
c. Ratio of output voltage to input voltage.
d. Ratio of out power delivers to load to input power given to transistor.
Gain of an amplifier
a. Ratio of output voltage to input voltage.
b. Ratio of input voltage to output voltage.
c. Ratio of out power to DC supply.
d. Ratio of out put voltage to load voltage.
Name the amplifier which inverts the input signal 180 degrees.
a. Non- inverting amplifier.
b. power amplifier.
c. inverting amplifier.
d. comparator.
Page 2 of 2