(i) Calculate the uniform distributed Live load (imposed action) per unit length of the edge and
the middle beam. (3 marks)
(ii) Calculate the uniform distributed Dead load (permanent action) per unit length of the edge
and the middle beam. Concrete weight per unit volume = 25 kN/m3 (Hint: You have to consider
the self-weight of the concrete deck slab and the steel girder in your calculations.) (3 marks)
*
(iii)Calculate the design bending moment M at mid-span of the edge and the middle beam under
the strength limit state load combination of 1.2G + 1.5Q. (4 marks)
250 mm
5.0 m
1200WB455
Edge steel beam
beam
1.5 m
12.0 m
Middle beam 1.5 m
1.5 m
Figure-1
1
QUESTION 2 (Tension member design) (30 Marks)
Select the minimum mass PFC for members AB, BC and CD of the truss shown in Figure-2. The point
loads due to permanent (G) and imposed (Q) actions are given in Figure-2 (Steel Grade 350). Ignore
the Self-weight of the truss (members) and assume that all connections are welded. The members
perpendicular to the plane of the truss are only connected to joints through pinned connections.
Hint: If the maximum available PFC size is not adequate then use double PFC.
Figure-2
Figure-3