RTP
If all router Ethernet interfaces in an EIGRP network are configured with the default
EIGRP timers, how long will a router wait by default to receive an EIGRP packet from its
neighbor before declaring the neighbor unreachable?
15 seconds
When an EIGRP-enabled router uses a password to accept routes from other EIGRP-
enabled routers, which mechanism is used?
EIGRP authentication
Why would a network administrator use a wildcard mask in the network command when
configuring a router to use EIGRP?
to exclude some interfaces from the EIGRP process
A new network administrator has been asked to verify the metrics that are used by
EIGRP on a Cisco device. Which two EIGRP metrics are measured by using static
values on a Cisco device? (Choose two.)
bandwidth
delay
Refer to the exhibit. Which command should be used to configure EIGRP to only
advertise the network that is attached to the gigabit Ethernet 0/1 interface?
network 172.16.23.64 0.0.0.63
Open the PT Activity. Perform the tasks in the activity instructions and then answer the
question.
Which code is displayed on the web server?
Complete
Which three metric weights are set to zero by default when costs in EIGRP are being
calculated? (Choose three.)
k4
k2
k5
Refer to the exhibit. R2 has two possible paths to the 192.168.10.4 network. What
would make the alternate route meet the feasibility condition?
a reported distance less than 3523840
Which table is used by EIGRP to store all routes that are learned from EIGRP
neighbors?
the topology table
Which bandwidth value is used when calculating the EIGRP metric of a route?
the slowest bandwidth of all outgoing interfaces between the source and destination
Which multicast address does an EIGRP-enabled router use to send query packets?
224.0.0.10
Refer to the exhibit. A network administrator is verifying the EIGRP configuration. Which
conclusion can be drawn?
Subnetted networks are included in route updates.
Which two values are included by default in the calculation of an EIGRP metric?
(Choose two.)
delay
bandwidth
In the command router eigrp 100, what does the value 100 represent?
the autonomous system number
What two conditions will result in an EIGRP route going into the active state? (Choose
two.)
The successor is down.
There is no feasible successor.
Which two protocols are allowed to be routed by EIGRP as a consequence of the PDM
feature? (Choose two.)
IPv4
IPv6
Which address will EIGRP for IPv6 use as the router ID?
the highest IPv4 address that is configured on any enabled interface
Refer to the exhibit. What does the value 2816 represent in the output display?
reported distance
What address and wild card mask can be used to enable EIGRP for only the subnet
192.168.100.192 255.255.255.192?
192.168.100.192 0.0.0.63
Match the types of EIGRP routes to the correct default administrative distances. (Not all
options are used.)
-summary
5
Match the types of EIGRP routes to the correct default administrative distances. (Not all
options are used.)
-internal
90
Match the types of EIGRP routes to the correct default administrative distances. (Not all
options are used.)
-external
170
Match the EIGRP packet type to the function. (Not all options are used.)
-used to confirm the reliable delivery of a packet
acknowledgment
Match the EIGRP packet type to the function. (Not all options are used.)
-used to form an EIGRP neighbor relationship
hello
Match the EIGRP packet type to the function. (Not all options are used.)
-used to distribute routing information
update
Match the EIGRP packet type to the function. (Not all options are used.)
-used in response to an EIGRP-enabled router searching for a network
reply